Mi-T-M 8 Gallon Work Pro Series Gasoline El manual del propietario

Marca: Mi-T-M

Modelo: 8 Gallon Work Pro Series Gasoline

Categoría: Compresores de aire

Tipo: El manual del propietario

Este manual también es adecuado para

Portable Gas

Mi-T-M

Gasoline Air Compressor Manual 1

GASOLINE

AIR COMPRESSOR

OPERATOR'S MANUAL

CAUTION

RISK OF INJURY! READ ENTIRE MANUAL

BEFORE OPERATING! THIS MANUAL IS AN IMPORTANT

PART OF THE AIR COMPRESSOR AND MUST REMAIN

WITH THIS UNIT WHEN YOU SELL OR RENT IT!

2 Mi-T-M

Gasoline Air Compressor Manual

TABLE OF CONTENTS

INTRODUCTION ................................................................................................................ 3

IMPORTANT ..................................................................................................................3

INSPECTION ......................................................................................................................3

SAFETY WARNINGS......................................................................................................4-7

RISK OF EXPLOSION OR FIRE ...........................................................................4

RISK OF BURSTING .............................................................................................5

RISK TO BREATHING ...........................................................................................5

RISK OF BURNS ...................................................................................................6

RISK OF FLYING OBJECTS ................................................................................. 6

RISK FROM MOVING PARTS .............................................................................. 6

RISK FROM NEGLIGENCE .................................................................................. 7

RISK OF AIR COMPRESSOR DAMAGE ..............................................................7

FEATURES DRAWINGS .......................................................................................... 8 & 10

FEATURES REVIEW .................................................................................................9 & 11

PREPARATION ................................................................................................................14

INITIAL SET-UP ...................................................................................................14

LOCATION ..........................................................................................................14

GASOLINE ENGINE ...........................................................................................14

PRE-START CHECKLIST ...................................................................................14

OPERATION ....................................................................................................................15

START-UP ...........................................................................................................15

SHUTDOWN .......................................................................................................15

MAINTENANCE ............................................................................................................... 15

TROUBLESHOOTING ................................................................................................16-17

WARRANTY ..................................................................................................................... 18

NOTES ..............................................................................................................................19

WARNING: This product can expose you to

chemicals including Lead, which is known to

the State of California to cause cancer and birth

defects or other reproductive harm. For more

information go to www.P65Warnings.ca.gov

WARNING

WARNING: This product can expose you to

chemicals including carbon monoxide, which is

known to the State of California to cause birth

defects or other reproductive harm. For more

information go to www.P65Warnings.ca.gov

WARNING

Mi-T-M

Gasoline Air Compressor Manual 3

IMPORTANT!

A "DANGER, WARNING or CAUTION" safety warning will be surrounded by a "SAFETY ALERT BOX".

This box is used to designate and emphasize Safety Warnings that must be followed when operating this

air compressor. Accompanying the safety warnings are "Signal Words" which designate the degree or

level of hazard seriousness. The "Signal Words" used in this manual are as follows:

DANGER: Indicates an imminently hazardous situation which, if not avoided,

WILL result in death or serious injury.

WARNING: Indicates a potentially hazardous situation which, if not avoided,

COULD result in death or serious injury.

CAUTION: Indicates a potentially hazardous situation which, if not avoided

MAY result in minor or moderate injury or damage to the air

compressor.

The symbols set to the left of this paragraph are "Safety Alert Symbols". These

symbols are used to call attention to items or procedures that could be

dangerous to you or other persons using this equipment.

ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ ALL

INSTRUCTIONS IN THIS MANUAL AND ANY INSTRUCTIONS SUPPLIED BY MANUFACTURERS OF

SUPPORTING EQUIPMENT BEFORE OPERATING THIS AIR COMPRESSOR AND ESPECIALLY POINT

OUT THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE

OPERATOR.

INSPECTION

Unbox the air compressor and write in the serial number in the space provided below. Inspect for signs of obvious

or concealed freight damage. Be sure that all damaged parts are replaced and any mechanical problems are

corrected prior to the operation of the air compressor.

SERIAL NUMBER_________________________________

If you have questions, contact your Mi-T-M

Customer Service Representative at 1-800-553-9053

Please have the following information available for all service calls:

1. Model Number

2. Serial Number

3. Date and Place of Purchase

Mi-T-M

Corporation 50 Mi-T-M Drive, Peosta, IA 52068

INTRODUCTION

Congratulations on the purchase of your new Mi-T-M

Air Compressor! You can be assured your Mi-T-M Air

Compressor was constructed with the highest level of precision and accuracy. Each component has been

rigorously tested by technicians to ensure the quality, endurance and performance of this air compressor.

This operator's manual was compiled for your benet. By reading and following the simple safety, installation and

operation, maintenance and troubleshooting steps described in this manual, you will receive years of troublefree

operation from your new Mi-T-M Air Compressor. The contents of this manual are based on the latest product

information available at the time of publication. Mi-T-M reserves the right to make changes in price, color,

materials equipment, specications or models at any time without notice.

4 Mi-T-M

Gasoline Air Compressor Manual

POTENTIAL CONSEQUENCE

PREVENTION

SAFETY WARNINGS

WARNING: WHEN USING THIS PRODUCT, BASIC PRECAUTIONS SHOULD ALWAYS BE OBSERVED, INCLUDING

THE FOLLOWING. READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR

RISK OF

EXPLOSION OR FIRE

Serious injury or death may occur

from normal sparks in the engine

ignition system or engine exhaust/

mufer.

Injury or death may occur as a

result of improper fueling.

Serious injury may occur if any air

compressor ventilation openings

are restricted, causing the air

compressor to overheat and start

a re.

Always operate air compressor

in a well ventilated area free of

ammable vapors, combustible

dust, gases or other combustible

materials.

DO NOT SMOKE if spraying

ammable material. Locate the air

compressor at least 20 feet away

from the spray area. (An additional

hose may be required.)

Do not smoke while lling engine

fuel tank.

Never ll the engine fuel tank while

the engine is running or hot. Allow

the engine to cool two minutes

before refueling.

Do not refuel indoors or in a poorly

ventilated area.

Always refuel slowly to avoid the

possibility of spilled fuel which may

cause a risk of re.

Do not operate the unit if gasoline

is spilled. Wipe the air compressor

clean and move it away from the

spill. Avoid creating any ignition

until the gasoline has evaporated.

Do not store the air compressor

near an open ame or any

equipment such as a stove,

furnace, water heater, etc. which

utilizes a pilot light or sparking

device.

A spark arrester must be added

to the mufer of this engine if it is

to be used on any forest covered,

brush covered or grass covered

unimproved land. The arrester

must be maintained in effective

working order by the operator.

Never place objects against or on

top of air compressor. Operate air

compressor at least 12 inches away

from any wall or obstruction that

would restrict proper ventilation.

HAZARD

Mi-T-M

Gasoline Air Compressor Manual 5

POTENTIAL CONSEQUENCE

PREVENTION

Serious injury or death may occur

from an air tank explosion if air

tanks are not properly maintained.

Serious injury may occur from

an air compressor malfunction or

exploding accessories if incorrect

system components, attachments

or accessories are used.

Drain air tank daily or after each

use to prevent moisture buildup in

the air tank.

If air tank develops a leak, replace

the air tank immediately. Never

repair, weld or make modications

to the air tank or its attachments.

Use only genuine Mi-T-M

repair

parts for your air compressor.

Never make adjustments to the

factory set pressures.

Never exceed manufacturers

maximum allowable pressure

rating of attachments.

Because of extreme heat, do

not use plastic pipe or lead tin

soldered joints for a discharge

line.

Never use air compressor to

inate small, low pressure objects

such as toys.

RISK OF

BURSTING

SAFETY WARNINGS

READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR

RISK TO

BREATHING

Serious injury or death could occur

from inhaling compressed air. The

air stream may contain carbon

monoxide, toxic vapors or solid

particles.

Serious injury or death may occur

from inhaling engine exhaust.

Sprayed materials such as paint,

paint solvents, paint remover,

insecticides, weed killers, etc.

contain harmful vapors and

poisons.

Never inhale air from the air

compressor either directly or from

a breathing device connected to

the air compressor.

This air compressor was designed

for outdoor use. Never operate

this air compressor in an enclosed

area. Always make certain there

is adequate ventilation (fresh

outside air) for breathing and

combustion. This will prevent

the buildup of dangerous carbon

monoxide gases. Beware of

poorly ventilated areas, or areas

with inadequate exhaust fans.

Operate air compressor only in

a well ventilated area. Follow all

safety instructions provided with

the materials you are spraying.

Use of a respirator may be

required when working with some

materials.

HAZARD

6 Mi-T-M

Gasoline Air Compressor Manual

POTENTIAL CONSEQUENCE

PREVENTION

RISK

OF BURNS

RISK

OF FLYING OBJECTS

Serious injury could occur

from touching exposed metal

parts. These areas can remain

hot for some time after the air

compressor is shutdown.

Soft tissue damage can occur

from the compressed air stream.

Serious injury can occur from

loose debris being propelled at a

high speed from the compressed

air stream.

Never allow any part of your body

or other materials to make contact

with any exposed metal parts on

the air compressor.

Never allow any part of your body

to contact the engine mufer or

adjacent areas.

Always wear safety glasses to

shield the eyes from ying debris.

Never point the air stream at any

part of your body, anyone else or

animals.

Never leave pressurized air in

the air compressor. Shut off air

compressor and relieve pressure

when storing or attempting

maintenance.

Always maintain a safe distance

from people and animals while

operating the air compressor.

Do not move the air compressor

while air tank is under pressure.

Do not attempt to move the air

compressor by pulling on the

hose.

SAFETY WARNINGS

READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR

RISK FROM

MOVING PARTS

Risk of bodily injury from moving

parts.

Before performing maintenance,

always turn off air compressor.

Bleed pressure from the air hose

and disconnect spark plug wire

to prevent engine from starting

unexpectedly. All repairs to the air

compressor should be made by an

Authorized Service person.

Do not operate without protective

covers/guards. Always turn off

air compressor before removing

any guard. Replace damaged

covers/guards before using the air

compressor.

HAZARD

Mi-T-M

Gasoline Air Compressor Manual 7

POTENTIAL CONSEQUENCE

PREVENTION

RISK FROM

NEGLIGENCE

RISK

OF AIR COMPRESSOR

DAMAGE

Risk of injury from negligent use.

Risk of major repair.

Never allow children or

adolescents to operate this air

compressor!

Stay alert-watch what you are

doing. Do not operate the air

compressor when fatigued or

under the inuence of alcohol or

drugs.

Know how to stop the air

compressor. Be thoroughly

familiar with controls.

Do not operate air compressor

without an air lter.

Do not operate air compressor in a

corrosive environment.

Always operate the air compressor

in a stable, secure position to

prevent air compressor from

falling.

Follow all maintenance

instructions listed in this manual.

! SAVE THESE INSTRUCTIONS !

SAFETY WARNINGS

READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR

HAZARD

8 Mi-T-M

Gasoline Air Compressor Manual

Mi-T-M GASOLINE AIR COMPRESSOR FEATURES

(SINGLE STAGE)

AC1-PH55-08 FEATURE-041205-DLG

AC1-PH55-20M W/THROTTLE CONTROL-041205-DLG

1. Decal: Danger/Warning/Caution

2. Tank Drain Valves

3. Decal- Warning: Hot

4. Pump Oil Drain

5. Oil Sight Glass

6. Pilot Valve

7. Engine Air Throttle Control

8. Engine Switch

9. Engine

10. Decal- Caution: Risk of Fire

11. Decal- Warning: Hot Surface

12. Pump Discharge Line

13. Beltguard

14. Decal- Warning: Risk of Injury

15. Decal- Warning: Beltguard

16. Air Filter

17. Oil Fill Port

18. Pump

19. Ventilation Openings

20. Pressure Gauge - Tank PSI

21. Pressure Relief Valve

22. Pressure Regulator

23. Pressure Gauge - Outlet PSI

24. Outlet Fitting

Mi-T-M

Gasoline Air Compressor Manual 9

SAFETY RELIEF VALVE: This valve is designed to prevent system failures by reliev-

ing pressure from the system when the compressed air reaches a predetermined level.

The valve is preset by the manufacturer and must not be modied in any way. To verify

the valve is working properly, pull on the ring. Air pressure should escape. When the

ring is released, it will reseat.

PILOT VALVE: When the toggle is in the upright position, all air from the air compressor

is vented through the discharge mufer. This gives an easy start feature. For normal

operation, the toggle is in the 90° position.

AIR INTAKE FILTER: This lter is designed to clean air coming into the pump. To

ensure the pump continually receives a clean, cool, dry air supply this lter must always

be clean and ventilation opening free from obstructions. Replace lter element when

necessary.

AIR TANK PRESSURE GAUGE: The air tank pressure gauge indicates the reserve

air pressure in the air tank (s).

PRESSURE REGULATOR: The air pressure coming from the air tank is controlled by

the regulator knob. Turn the pressure regulation knob clockwise to increase discharge

pressure, and counterclockwise to decrease discharge pressure. (Actual delivered

pressure may vary from pump maximum pressure rating)

OUTLET PRESSURE GAUGE: The outlet pressure gauge indicates the air pressure

available at the outlet side of the regulator. This pressure is controlled by the regulator

and is always less or equal to the air tank pressure.

AIR TANK DRAIN VALVE: The drain valve is used to remove moisture from the air

tank(s) after the air compressor is shut off. NEVER attempt to open the drain valve

when more than 10 PSI of air pressure is in the air tank! To open the drain valve,

turn the knob counterclockwise.

EXPLODED VIEW & EXPLANATION OF AIR COMPRESSOR FEATURES

OIL FILL PORT/VENT: Pour oil into the Oil Fill Port/Vent when required.

OIL SIGHT GLASS: The Oil Sight Glass displays the oil level in the pump. The oil

level should be at the center of the Oil Sight Glass. If low, add SAE 30W non-deter-

gent oil.

AIR COMPRESSOR PUMP: To compress air, the pistons move up and down in the

cylinders. On the downstroke, air is drawn in through the air intake valves while the

exhaust valves remain closed. On the upstroke, air is compressed, the intake valves

close and compressed air is forced out through the exhaust valves, into the discharge

line, through the pilot valve and into the air tank.

1. Decal: Danger/Warning/Caution

2. Tank Drain Valves

3. Decal- Warning: Hot

4. Pump Oil Drain

5. Oil Sight Glass

6. Pilot Valve

7. Engine Air Throttle Control

8. Engine Switch

9. Engine

10. Decal- Caution: Risk of Fire

11. Decal- Warning: Hot Surface

12. Pump Discharge Line

13. Beltguard

14. Decal- Warning: Risk of Injury

15. Decal- Warning: Beltguard

16. Air Filter

17. Oil Fill Port

18. Pump

19. Ventilation Openings

20. Pressure Gauge - Tank PSI

21. Pressure Relief Valve

22. Pressure Regulator

23. Pressure Gauge - Outlet PSI

24. Outlet Fitting

10 Mi-T-M

Gasoline Air Compressor Manual

Mi-T-M GASOLINE AIR COMPRESSOR FEATURES

(TWO STAGE)

AC2-PH08-PV09-20-FEATURE-012704-DLG AC2-PH08-PV09-FEATURES-012704-DLG

1. Decal- Warning: Hot Surfaces

2. Decal- Warning: Risk of Fire

3. Engine

4. Engine Switch

5. Engine Throttle Control

6. Pilot Valve

7. Oil Fill Port

8. Pump Oil Sight Glass

9. Pump Oil Drain

10. Decal- Warning: Hot

11. Decal- Danger/Warning/Caution

12. Pressure Relief Valve

13. Tank Drain Valves

14. Pressure Gauge- Tank PSI

15. Pressure Gauge- Outlet PSI

16. Pressure Regulator

17. Ventilation Openings

18. Air Compressor Pump

19. Air Filter

20. Decal- Warning: Beltguard

21. Decal- Warning: Injury

22. Beltguard

AS2-PH08-PR09-PV09-08 FEATURES-012704-DLG

AM2-SH09-B-FEATURE-011509-RSW

Mi-T-M

Gasoline Air Compressor Manual 11

EXPLODED VIEW & EXPLANATION OF AIR COMPRESSOR FEATURES

SAFETY RELIEF VALVE: This valve is designed to prevent system failures by re-

lieving pressure from the system when the compressed air reaches a predetermined

level. The valve is preset by the manufacturer and must not be modied in any way.

To verify the valve is working properly, pull on the ring. Air pressure should escape.

When the ring is released, it will reseat.

PILOT VALVE: When the toggle is in the upright position, all air from the air compres-

sor is vented through the discharge mufer. This gives an easy start feature. For

normal operation, the toggle is in the 90° position.

AIR INTAKE FILTER: This lter is designed to clean air coming into the pump. To

ensure the pump continually receives a clean, cool, dry air supply this lter must al-

ways be clean and ventilation opening free from obstructions. Replace lter element

when necessary.

AIR TANK PRESSURE GAUGE: The air tank pressure gauge indicates the reserve

air pressure in the air tank (s).

PRESSURE REGULATOR: The air pressure coming from the air tank is controlled by

the regulator knob. Turn the pressure regulation knob clockwise to increase discharge

pressure, and counterclockwise to decrease discharge pressure. (Actual delivered

pressure may vary from pump maximum pressure rating)

OUTLET PRESSURE GAUGE: The outlet pressure gauge indicates the air pressure

available at the outlet side of the regulator. This pressure is controlled by the regulator

and is always less or equal to the air tank pressure.

AIR TANK DRAIN VALVE: The drain valve is used to remove moisture from the air

tank(s) after the air compressor is shut off. NEVER attempt to open the drain valve

when more than 10 PSI of air pressure is in the air tank! To open the drain valve,

turn the knob counterclockwise.

AIR COMPRESSOR PUMP: A two stage compressor pump uses two different size

cylinders with the intake valve of the second smaller cylinder linked to the exhaust

valve of the rst larger cylinder. On the down stroke of the large cylinder, air is drawn

through the intake valve while the exhaust valve remains closed. On the upstroke, air

is compressed, the intake valve closes and compressed air is forced out through the

exhaust valve, into the inter cooler and through the intake valve of the second smaller

cylinder on its down stroke. On the upstroke of the smaller cylinder, the intake valve

closes and the compressed air is compressed a second time and forced out the exhaust

valve into the discharge line, through the tank check valve and into the air tank.

OIL FILL PORT

OIL SIGHT GLASS

OIL FILL PORT/VENT: Pour oil into the Oil Fill Port/Vent when required.

OIL SIGHT GLASS: The Oil Sight Glass displays the oil level in the pump. The oil

level should be at the center of the Oil Sight Glass. If low, add SAE 30W non-deter-

gent oil.

12 Mi-T-M

Gasoline Air Compressor Manual

NOTES

Mi-T-M

Gasoline Air Compressor Manual 13

WARNING

THE FOLLOWING PAGES CONTAIN OPERATING AND MAINTENANCE

INSTRUCTIONS.

DO NOT ATTEMPT TO OPERATE THIS AIR COMPRESSOR UNTIL YOU

HAVE READ AND UNDERSTOOD ALL SAFETY PRECAUTIONS AND

INSTRUCTIONS LISTED IN THIS MANUAL.

INCORRECT OPERATION OF THIS UNIT CAN CAUSE SERIOUS

INJURY!!

DO NOT ALTER OR MODIFY THIS EQUIPMENT IN ANY MATTER!

14 Mi-T-M

Gasoline Air Compressor Manual

INITIAL SET-UP:

1. Read safety warnings before setting-up air compressor.

2. Ensure the oil level in the air compressor pump is adequate. If low,

add SAE 30W non-detergent oil.

LOCATION:

1. In order to avoid damaging the air compressor, do not incline the air

compressor transversely or longitudinally more than 10°.

2. Place air compressor at least 12 inches away from obstacles that may

prevent proper ventilation. Do not place air compressor in an area:

-where there is evidence of oil or gas leaks.

-where ammable gas vapors or materials may be present.

-where air temperatures fall below 32°F or exceed 104°F.

-where extremely dirty air or water could be drawn into the air

compressor.

GASOLINE ENGINE:

1. Review "Risk of Fire or Explosion" pg. 4 before fueling.

2. Read the engine manual accompanying this air compressor for

correct engine start-up maintenance procedures.

3. Read and understand the safety labels located on the air compressor.

4. A minimum of 86 octane fuel is recommended for use with this air

compressor. Do not mix oil with gasoline.

5. Use of clean, fresh, lead free gasoline is recommended. Leaded gasoline

may be used if lead free is not available. Do not use gasoline

containing methanol or alcohol.

6. Check the engine oil level before starting. (See engine manual.)

7. Fill the fuel tank according to the engine manual instruction.

8. Refer to the engine manual for all necessary maintenance and

adjustments.

PRE-START CHECKLIST:

1. Check oil level. Add if necessary.

2. Remove any moisture in the air compressor air tank. NEVER

attempt to open the Air Tank Drain Valve when more than

10 PSI of air pressure is in the air tank! Remove excessive

pressure with an air tool, then open the Air Tank Drain Valve in the bottom

of the air tank. Close tightly when drained.

3. Make sure the Engine Switch is in the "OFF" position.

4. Make sure the Safety Relief Valve is working correctly.

5. Make sure all guards and covers are in place and securely mounted.

PREPARATION

WARNING

RISK OF BODILY INJURY!

Never attempt to open the

Air Tank Drain Valve when

more than 10 PSI of air

pressure is in the air tank!

WARNING

RISK OF EXPLOSION OR FIRE

CAUSING SERIOUS INJURY

OR DEATH!

Do not allow the engine or

mufer to come in contact

with ammable vapors, com-

bustible dust, gases or other

combustible materials. A

spark may cause a re.

When using the air compres-

sor for spray painting, place

the air compressor as far

away from the work area as

possible, using extra air hoses

if needed.

DANGER

RISK OF EXPLOSION OR FIRE

CAUSING SERIOUS INJURY

OR DEATH!

Do not smoke while fueling!

Do not ll fuel tank while air

compressor is running or hot.

Allow air compressor and

engine to cool down for two

minutes before refueling.

Do not ll fuel tank to point

of overflowing. Allow

approximately 1/4" of tank

space for fuel expansion.

WARNING

RISK OF EXPLOSION OR FIRE

CAUSING SERIOUS INJURY

OR DEATH!

Do not place unit in an area

where ammable gas vapors

may be present. A spark could

cause an explosion or re.

Always store fuel away from

the air compressor while it is

running or hot.

WARNING

RISK OF ASPHYXIATION!

Do not operate in an enclosed

area. Use this product only

in well ventilated areas! The

exhaust from the engine

contains carbon monoxide,

a poisonous, odorless and

invisible gas. Breathing the

gas can cause serious injury,

illness and possible death.

Mi-T-M

Gasoline Air Compressor Manual 15

OPERATION

START-UP:

1. Read safety warnings before performing operation.

2. Flip the toggle on top of the Pilot Valve to the upright position. This provides a loadless start. The air

compressor will unload and allow easier engine start-up.

3. Start the engine. (Refer to the Engine Manual accompanying this unit.)

4. When the engine has run for 1-2 minutes, ip toggle back to the original position.

5. Set pressure by adjusting the Pressure Regulator counterclockwise for less pressure and clockwise for more

pressure.

6. If you notice any unusual noise or vibration, stop the air compressor and refer to "Troubleshooting".

SHUTDOWN:

1. To stop the air compressor, move the Engine Switch to the "Off" position. (Refer to the Engine Manual

accompanying this unit.)

2. Drain air from the air tanks by releasing air with an attached air tool or by pulling on the Safety Relief

Valve.

3. Once the Air Tank Pressure Gauge registers under 10 pounds, open the drain valve under each air tank to

drain any moisture.

4. Allow the air compressor to cool down.

5. Wipe air compressor clean and store in a safe, non-freezing area.

MAINTENANCE

Read the instruction manual before performing maintenance. The following procedures must be performed

when stopping the air compressor for maintenance or service.

1. Turn off air compressor.

2. Disconnect spark plug wire from engine.

3. Open all drains.

4. Wait for the air compressor to cool before starting service.

MAINTENANCE CHART

*The pump oil must be changed after the rst 50 hours of operation and every 200 hours or 3 months,

whichever comes rst.

The engine oil must be changed after the rst 8 hours of operation and every 50 hours or 3 months, whichever

comes rst.

Every 2 years, an Authorized Service Technician should check the check valve, intake valves and delivery

valves.

AC Gas Maintenance Chart

MAINTENANCE CHART

PROCEDURE DAILY WEEKLY

MONTHLY 200 HOURS

Check pump oil level X

Check engine oil level X

Oil leak inspection X

Check engine air filter X

Drain condensation in air tank (s) X

Inspect guards/covers X

Check for unusual noise/vibration X

Check for air leaks X

Clean exterior of compressor X

Inspect air filter X

Inspect belt X

Check safety relief valve X

Change pump oil * X

Replace air filter X

Check engine spark plug X

16 Mi-T-M

Gasoline Air Compressor Manual

TROUBLESHOOTING

SYMPTOM PROBABLE CAUSE REMEDY

Engine will not start.

Various engine problems.

Refer to the engine manual

accompanying your air compressor.

Noisy operation.

Loose engine pulley or pump

ywheel.

Lack of oil in the pump.

Carbon deposits on pistons or

valves.

Bearing, piston or connecting rod

failure.

Tighten pulley and or ywheel.

Add correct amount of oil. Check for

bearing damage.

Remove cylinder head and inspect.

Clean or replace.

STOP THE AIR COMPRESSOR!

Contact Mi-T-M Customer Service.

Air leaks at connections. Allow air compressor to build pres-

sure to the maximum allowed. Turn

off and brush a soapy water solution

onto all connections. Check connec-

tions for air bubbles. Tighten the con-

nections where leaks are present.

Air leak in air tank.

Defective Pilot Valve.

Air tank must be replaced. Do not

attempt to repair air tank!

Clean or replace.

Insufcient pressure at air tool

or accessory.

Pressure Regulator not turned to

high enough pressure or defec-

tive.

Restricted air intake .

Air leaks or restrictions.

Hose or hose connections are too

small or long.

Slipping belt.

Air compressor is not large

enough for air requirement.

Restriction in Pilot Valve.

Adjust Pressure Regulator to proper

setting or replace.

Clean or replace Air Intake Filter.

Check for leaks and repair.

Replace with larger hose or

connectors.

Tighten or replace.

Check the accessory air requirement.

If it is higher than the CFM or pres-

sure supply to the air compressor, use

a larger air compressor.

Clean or replace.

Pressure drop in air tank or

rapid pressure loss when air

compressor is shut off.

Air leaks from Safety Relief

Valve

Possible defective Safety Relief

Valve.

Excessive air tank pressure.

Operate Safety Relief Valve manually

by pulling on ring. If it still leaks, it

should be replaced.

Clean, reset or replace Pilot Valve.

Low engine oil level.

Engine is equipped with an Oil Alert

System which will not allow the en-

gine to start if oil level is low. Add oil,

if needed.

Mi-T-M

Gasoline Air Compressor Manual 17

TROUBLESHOOTING

SYMPTOM PROBABLE CAUSE REMEDY

Excessive oil consumption or oil

in hose.

Restricted Air Intake Filter.

Air compressor on unlevel surface.

Crankcase overlled with oil.

Wrong viscosity.

Plugged oil dipstick vent.

Plugged crankcase breather.

Oil leaks.

Worn piston rings or scored cylin-

der.

Clean or replace.

Do not incline the air compressor

more than 10° in any direction while

running.

Drain oil. Rell to proper level with

SAE-30W non-detergent oil.

Drain oil. Rell to proper level with

SAE-30W non-detergent oil.

Clean.

Clean or replace.

Torque head bolts: Single Stage=

17 ft./lbs. Two Stage= 33 ft./lbs.

Contact Mi-T-M Customer Service.

Oil has milky appearance. Water in oil due to condensation.

Change oil and move air compressor

to a less humid environment.

Air leaks at pump. Defective gaskets.

Torque head bolts: Single Stage= 17

ft./lbs. Two Stage= 33 ft./lbs.

Air blowing from Air Intake

Filter.

Defective inlet (reed) valve. Contact Mi-T-M Customer Service.

Condensation in air tank caused by

high level of atmospheric humidity

or air compressor is not run long

enough.

Run air compressor a minimum of

one hour to prevent condensation

buildup. Drain air tank after every

use. Drain air tank more often in hu-

mid weather and use an air line lter.

Moisture in discharge air.

18 Mi-T-M

Gasoline Air Compressor Manual

Mi-T-M GASOLINE AIR COMPRESSOR

STATEMENT OF WARRANTY

Mi-T-M Corporation warrants all parts, (except those referred to below), of your new air compressor to be free

from defects in materials and workmanship during the following periods:

For Two (2) years from the date of original purchase:

Compressor Pump Plumbing

Tank Assembly

For Six (6) months from date of original purchase:

Pressure Switch Regulator

Check Valve Pilot Valve

Copper/stainless steel line

For Ninety (90) days from the date of original purchase:

Pressure Gauges Safety Relief Valves

Drain Valves

Defective parts not subject to normal wear and tear will be repaired or replaced at our option during the warranty

period. In any event, reimbursement is limited to the purchase price paid.

EXCLUSIONS

1. Engine is covered under separate warranty by its respective manufacturer and is subject to the terms set

forth therein.

2. Normal wear parts:

Isolators Air Filter

3. This warranty does not cover parts damaged due to normal wear, abnormal conditions, misapplication,

misuse, accidents, operation at other than recommended speeds, pressures or temperature, improper storage

or freight damage. Parts damaged or worn by operation in dusty environments are not warranted. Failure to

follow recommended operating and maintenance procedures also voids warranty.

4. Labor charges, loss or damage resulting from improper operation, maintenance (other than routine air tank

draining and oil changes, if applicable) or repairs made by persons other than a Mi-T-M Authorized Service

Center.

5. The use of other than Genuine Repair Parts will void warranty. Parts returned, prepaid to our factory or to

an Authorized Service Center will be inspected and replaced free of charge if found to be defective and subject

to warranty. Under no circumstances shall the manufacturer bear any responsibility for loss of use of the unit,

loss of time or rental, inconvenience, commercial loss or consequential damages. There are no warranties

which extend beyond the description of the face hereof.

For Service or Warranty consideration, contact:

Mi-T-M Corporation, 50 Mi-T-M Drive, Peosta, IA 52068-0050

563-556-7484 / 800-553-9053 / Fax 563-556-1235

Monday-Friday 8:00 a.m. - 5:00 p.m. CST

Mi-T-M

Manual de operador de compresor de aire gasolina. 19

NOTES

20 Mi-T-M

Manual de operador de compresor de aire gasolina.

TABLA DE MATERIAS

INTRODUCCION ..............................................................................................................21

IMPORTANTE .............................................................................................................. 21

INSPECCIONE .................................................................................................................21

ADVERTENCIAS IMPORTANTES DE SEGURIDAD .................................................22-25

RIESGO DE EXPLOSIÓN ...................................................................................22

RIESGO DE ESTALLIDO ....................................................................................23

RIESGOS A LA RESPIRACIÓN ..........................................................................23

RIESGO DE QUEMADURAS ..............................................................................24

RIESGO DE OBJETOS VOLANTES ...................................................................24

RIESGO DE PARTES EN MOVIMIENTO ...........................................................24

RIESGO DE NEGLIGENCIA ...............................................................................25

RIESGO DE AVERÍAS DEL COMPRESOR DE AIRE ......................................... 25

ILUSTRACIONES DE LOS ELEMENTOS Y COMPONENTES ............................ 26 & 28

REPASO DE LOS ELEMENTOS Y COMPONENTES ........................................... 27 & 29

INSTRUCCIONES DE PREPARACIÓN ..........................................................................31

PREPARACIÓN ...................................................................................................31

COLOCACIÓN ....................................................................................................31

MOTOR DE GASOLINA ...................................................................................... 31

CONTROLES ANTES DEL ARRANQUE ............................................................31

INSTRUCCIONES DE OPERACIÓN ............................................................................... 32

OPERACIÓN ....................................................................................................... 32

APAGAMIENTO ...................................................................................................32

MANTENIMIENTO ...........................................................................................................32

LOCALIZACIÓN AVERÍAS ......................................................................................... 33-34

DECLARACIÓN DE GARANTÍA ..................................................................................... 35

ADVERTENCIA: Este producto puede

exponerlo a productos químicos, incluido el

plomo, que el Estado de California conoce a

causar cáncer y defectos congénitos u otros

daños reproductivos. Para obtener más

información, visite www.P65Warnings.ca.gov

ADVERTENCIA

ADVERTENCIA: Este producto puede expo-

nerle a químicos incluyendo carbon monoxide,

que es conocido por el Estado de California

como causante de defectos de nacimiento u

otros daños reproductivos. Para mayor

información, visite www.P65Warnings.ca.gov.

ADVERTENCIA

Mi-T-M

Manual de operador de compresor de aire gasolina. 21

INTRODUCCION

¡Felicitaciones por la compra de su nueva compresor de aire gasolina! Puede estar seguro que su compresor

de aire gasolina fue construida con el nivel más. Cada componente ha sido probado rigurosamente por técnicos

para asegurar la calidad, la resistencia y el rendimiento de esta unidad.

Este manual del operador fue compilado para su benecio. Leyendo y siguiendo los pasos simples de seguridad,

instalación, operación, mantenimiento y localización de fallas descritos en este manual ayudará a prolongar

aun más la operación libre de fallas que usted puede esperar de su compresor de aire gasolina. El contenido

de este manual está basado en la información actualizada disponible al momento de la publicación. Mi-T-M

se reserva el derecho de efectuar cambios en precio, color, materiales, equipo, especicaciones o modelos en

cualquier momento sin previo aviso.

¡IMPORTANTE!

PROVEA SIEMPRE UNA COPIA DE ESTE MANUAL A CUALQUIER PERSONA QUE USE ESTE EQUIPO.

LEA TODAS LAS INSTRUCCIONES ANTES DE OPERAR ESTA LAVADORA A PRESION, OBSERVANDO

EN PARTICULAR LAS “ADVERTENCIAS DE SEGURIDAD” PARA EVITAR LA POSIBILIDAD DE LESIONES

PERSONALES AL OPERADOR.

Escriba el número de serie de su unidad en el espacio provisto abajo, una vez que la unidad haya sido

desempacada.

NUMERO DE SERIE___________________________

Inspeccione por daño el contenido de la caja. Si algo parece dañado, NO LA DEVUELVA AL LUGAR DE

COMPRA. Llame a su representante de servicio al cliente de al 800-553-9053.

Por favor tenga disponible la información siguiente para todas las llamadas de servicio:

1. Número de modelo

2. Número de serie

3. Fecha y lugar de compra

Mi-T-M

Corporation

50 Mi-T-M Drive

Peosta, IA 52068-0050

Estos párrafos están rodeados por una “CASILLA DE ALERTA DE SEGURIDAD”. Esta casilla

se usa par designar y enfatizar las Advertencias de Seguridad que deben seguirse al operar

esta lavadora a presión. Acompañando a las Advertencias de Seguridad están las “palabras

de alerta” que designan el grado o nivel de seriedad de riesgo. Las “palabras de alerta”

usadas en este manual son las siguientes:

PELIGRO: Indica una situación inminente riesgosa la cual, si no se evita, RESULTARA

en la muerte o en lesiones graves.

ADVERTENCIA: Indica una situación potencialmente riesgosa la cual, si no se

evita, PODRIA resultar en la muerte o en lesiones graves.

PRECAUCION: Indica una situación potencialmente riesgosa la cual, si no se evita

PUEDE resultar en lesiones menores o moderadas.

El símbolo indicado a la izquierda de este párrafo es el “Símbolo de Alerta de Seguridad”.

Este símbolo se usa para alertarlo acerca de artículos o procedimientos que podrían ser

peligrosos para usted u otras personas usando este equipo.

22 Mi-T-M

Manual de operador de compresor de aire gasolina.

ADVERTENCIAS IMPORTANTES DE SEGURIDAD

ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes:

LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE.

RIESGO DE EXPLOSIÓN O

DE INCENDIO

O fuego chipas normales de

sistema de encendido del motor

o de exhosto de motor/moe

puede causar lesiones graves y la

muerte. .

Un resulto de abastecer de

combustible incorrecto es lesiones

graves y la muerte.

Abiertas limitados de ventilación

de compresor de aire puded

causar lesiones graves. Necesitar

ventilación para evitar excesivo

calor y empieza del fuego.

Siempre funcionar el compresor

de aire en ambientes de bien

ventilados sin vapores amables,

polvos combusible, gases, o toras

materiales combustibles.

No fumar si pulverizando

materiales amables. Poner el

compresor de aire más de 20

pisos de ambiente de pulverizar.

(Puede necesitar un otro tubo.)

No fumar cuando llenar el tanque

de motor con combustible (fuel).

Nunca llenar el tanque del motor

con fuel cuando motor es calor o

funcionamiento. Permitir el motor

2 (dos) minutos para enifriarse

antes de más fuel.

No dar más fuel adentro o en

ambientes con mal ventilados.

Siempre reabastecer de fuel

despacio para evitar derrames

que puede causar riesgo de

fuego.

No funcionar el unito si hay

derrames de gasolina. Limpiar el

compresor de aire y mover afuera

de derrame. Evitar encendido

o funcionar hasta gasolina ha

evaporar.

No guardar el compresor de aire

cerca de fuegos o máquinas como

una estufa, horno, calentador de

agua, etc. cual utilizar una luz

pilota o dispositivo de chispas.

Necesitar tener arrestador de

chispas en el moee de este

motor para usar con algo tierra

que tener hierba o arboles. Esta

parte mantener efectuar por

operador.

No poner objectos cerca o arriba

de compresor de aire. Funcionar

compresor de aire más de 12

pulgudos afuera de pared o

obstrución que limitar ventilación

apropriado.

POSIBLE CONSECUENCIA PREVENCIÓN

PELIGRO

Mi-T-M

Manual de operador de compresor de aire gasolina. 23

Si no se respeta el mantenimiento

adecuado el depósito de aire podría

estallar y causar lesiones graves o

la muerte.

El funcionamiento incorrecto del

compresor o, en el caso en que se

empleen componentes o accesorios

inadecuados, el estallido de sus

accesorios podría causar lesiones

graves o la muerte.

Vaciar el depósito de aire todos

los días o al nal de cada uso,

para evitar que se acumule la

condensación.

Si el depósito de aire tiene una

fuga, sustituirlo inmediatamente. No

reparar, soldar o modicar jamàs el

depósito de aire o sus accesorios.

Usar sólo piezas originales para el

compresor de aire.

No modicar jamàs las presiones

ajustadas en al fàbrica.

No superar jamàs las presiones

màximas permitidas de los

accesorios, recomendadas por el

fabricante.

Debido al excesivo calor, no usar

tubos de plàstico o uniones con

soldaduras de plomo en la línea de

descarga.

No usar jamás un compresor de aire

para inar objetos pequeños o que

requieren poca presión como los

juguetes.

RIESGO DE ESTALLIDO

RIESGOS A LA RESPIRACIÓN

La inhalación de aire comprimido

puede causar lesiones graves e

incluso la muerte. El chorro de

aire podría contener monóxido

de carbono, vapores tóxicos o

partículas sólidas.

La inhalación de gases de motor

puede causar lesiones graves y la

muerte.

Materiales pulverizados como

pinturas, solventes para pinturas,

desbarnizadores, insecticidas,

herbicidas, etc. contienen vapores

dañinos y venenos.

No inhalar jamás el aire porcedente

del compresor de aire ni a través de

cualquier dispositivo de respricaión

conectado al compresor de aire.

Este compresor de aire se disenado

para funcionar en aire libre. Nunca

funcionar este compresor de aire

en ambientes cerrados, empre

tener ventilación adecuado. Este

prevenirá la acumule de gases

peligros que contener monóxido de

carbono. Ten ciudad de ambientes

de mal ventilados.

El compresor de aire debe funcionar

sólo en ambientes bien ventilados.

Atenerse a las instrucciones de

seguridad indicadas para los

materiales que se pulverizan. Al

pulverizar ciertos materiales podría

ser necesario usar un respirador.

ADVERTENCIAS IMPORTANTES DE SEGURIDAD

ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes:

LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE.

POSIBLE CONSECUENCIA PREVENCIÓN

PELIGRO

24 Mi-T-M

Manual de operador de compresor de aire gasolina.

RIESGO DE QUEMADURAS

El tocar partes metálicas

expuestas podría causar lesiones

graves. La temperatura en estas

zonas no baja inmediatamente al

apagar el compresor de aire.

El chorro de aire comprimido

podría causar lesiones a los

tejidos blandos.

La proyección de partículas del

chorro de aire comprimido a

velocidad elevada puede causar

lesiones graves.

Asegurarase que ninguna parte

del cuerpo o de otros materiales

entre en contacto con las

partes metálicas expuestas del

compresor de aire.

Nunca tener contacto de su

cuerpo y el moetle del motor o

ambientes adyacentes.

Usar siempre las gafas de

protección para proteger los ojos

de las particulas volantes.

No dirigir jamás el chorro de aire a

cualquier parte de su cuerpo o del

cuerpo de otra persona o animal.

No dejar jamás un compresor

de aire bajo presión sin

vigilancia. Apagar el compresor

y descargar la presión antes de

efectuar cualquier operación de

mantenimiento, conectar cualquier

herramienta o accesorio.

Con el compresor de aire en

marcha mantener siempre

una distancia de seguridad de

presonas y animales.

No debe moverse el compresor

de aire cuando el depósito de

aire está bajo presión. No intentar

mover el compresor de aire

tirando del tubo.

RIESGO DE PARTES EN

MOVIMIENTO

Riesgo de lesiones graves de

partes en movimiento.

Antes de hacer mantemiento

siempre parar el compresor de aire.

Purgar presión de tubo de aire y

desmontar el cable de bomba de

chispa para impedir el encendido

de motor. Todas reparaciones

hacer de personas autorizadas de

servicio.

No usar el compresor de aire sin las

protecciones de seguridad. Siempre

remova el enchufe del compresor

del aire antes de remover cualquier

guarda. Sustituir las protecciones

dañadas antes de encender le

compresor de aire.

ADVERTENCIAS IMPORTANTES DE SEGURIDAD

ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes:

LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE.

POSIBLE CONSECUENCIA PREVENCIÓN

RIESGO DE OBJETOS

VOLANTES

PELIGRO

Mi-T-M

Manual de operador de compresor de aire gasolina. 25

RIESGO DE NEGLIGENCIA

RIESGO DE AVERÍAS DEL

COMPRESOR DE AIRE

Un uso negligente del compresor

puede ocasionar lesiones.

Riesgo de graves averías.

No permitir jamás que niños o

adolescentes pongan en marcha

el compresor de aire.

Prestar mucha atención a

la operación que se está

cumpliendo. No se debe poner

en marcha el compresor de aire

en caso de cansancio o bajo la

inuencia de alcohol o drogas.

Es necesario saber apagar el

compresor de aire. Es preciso

conocer bien todos los mandos.

No encender el compresor de aire

sin el ltro de aire.

No encender el compresor de aire

sin el ltro de aire.

No encender el compresor de

aire en un ambiente corrosivo. El

compresor de aire debe funcionar

en una posición estable y segura

para prevenir que caiga.

Atenerse a las instrucciones de

mantenimiento descritas en este

manual.

ADVERTENCIAS IMPORTANTES DE SEGURIDAD

ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes:

LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE.

POSIBLE CONSECUENCIA PREVENCIÓN

¡GUARDE ESTAS INSTRUCCIONES!

PELIGRO

26 Mi-T-M

Manual de operador de compresor de aire gasolina.

Mi-T-M COMPONENTES DE COMPRESOR DE AIRE GASOLINA

(ESTAPA SENCILLA)

1. Calcomanía- Peligro/Advertencia/

Precaución

2. Válvula (s) de descargar del tanque

de aire

3. Calcomanía- Advertencia: Calientes

4. Sumidero del aceite de bomba

5. Cristal De la Vista Del Aceite

6. Válvula de piloto

7. Control de regulador de motor

8. Interruptor de motor

9. Motor

10. Calcomanía- Riesgo de Incendido

11. Calcomanía- Advertencia:

Supercies Calientes

12. Cuerda de depósito de bomba

13. Guardia del cintúron

14. Calcomanía- Advertencia:

Riesgo de lesiones

15. Calcomanía- Advertencia:

Guardia del cintúron está en lugar

16. Filtro de aire

17. Puerto de relleno del aceite

18. Bomba

19. Abiertas de ventilación

20. Indicador de presión de tanque

de aire

21. Valvula de alivio de presión

22. Regulador de presión

23. Indicador de presión de salida

24. Instalaciónes de salida

AC1-PH55-08 FEATURE-041205-DLG

AC1-PH55-20M W/THROTTLE CONTROL-041205-DLG

Mi-T-M

Manual de operador de compresor de aire gasolina. 27

VÁLVULA DE ALIVIO DE SEGURIDAD: Esta válvula sea diseñado para prevenir

falla de la sistema por aliviando alcance un nivel predeterminado. La válvula ha pre-

programado por el fabricante y no puede modicar en ninguna manera. Para vericar

que la válvula está trabajando correctamente, tire en el anillo. Presión de aire debe

escapar. Cuando el anillo sea liberado, lo volver a cero.

VÁLVULA DE PILOTO: Cuando el muletilla está en posición vertical, todo el aire de

compresor de aire descargó por el moe de depósito. Este da una característica de en-

cender fácil. Para operación normal la muletilla está en posición de noventa grados.

FILTRO DE LA ENTRADA DEL AIRE: Este ltro sea diseñado para limpiar aire que

veniendo en la bomba. Para asegurar la bomba reciba continuamente un suministro

de aire limpio, fresco, y seco el ltro tiene que ser limpio y el abierto de ventilación no

tiene obstruciónes. Reemplace el elemento del ltro cuando necesario.

INDICADOR DE PRESIÓN DE TANQUE DE AIRE: El indicador de presión de tanque

de aire indica la presión de aire reserva en los tanques de aire.

REGULADOR DE PRESIÓN: La presión de aire veniendo de tanque de aire sea

controlado por la perilla de regulador. Gire la perilla de regulación de presión de las

agujas del reloj para aumentar presión descarga y en sentido contrario a las aguajas

del reloj para disminuir la presión descarga. (La presión real de entrega pueden variar

de un nivel de presión máxima de la bomba).

INDICADOR DE PRESIÓN SALIDA: El indicador de presión salida indica la presión

de aire disponsible en el lado de salida del regulador. Esta presión sea controlado por

el regulador y siempre sea menos o igual a la presión de tanque de aire.

VÁLVULA DE DESCARGAR DEL TANQUE DE AIRE: La válvula de descargar sea

usado para quitar la humedad de las tanques de aire despues de apagarse del com-

presor de aire. NUNCA trate abrir la válvula de descargar cuando más de 10PSI

de presión de aire está en el tanque de aire! Para abrir la válvula de descargar, gire

la perilla en sentido contrario a las agujas.

VISTA EXPLOTADA & EXPLICACIÓN DE ELEMENTOS DE COMPRESOR DE AIRE

BOMBA DE COMPRESOR DE AIRE: Para comprimir aire, los pistones mueven arriba

y abajo en los cinlindros. En el tiempo abajo aire sea retraido por las válvulas entradas

mientras las válvulas de exhausto quedan cerrado. En el tiempo arriba el aire sea com-

primido, las válvulas entradas cierran y aire comprimido sean forzados por las válvulas

de exhausto en la linea descarga por la válvula pilota y en el tanque de aire.

PUERTO DE RELLENO DEL ACEITE / TIRO: Tire el aceite en el puerto de relleno

del aceite / tiro cuando necesario.

VIDRIO DE VISTA DEL ACEITE: El vidrio de vista del aceite expone el nivel del aceite

en la bomba. El nivel del aceite debe estar en el medio del vidrio de vista del aceite. Si

bajo agregue SAE30W aceite sin detergente.

28 Mi-T-M

Manual de operador de compresor de aire gasolina.

Mi-T-M COMPONENTES DE COMPRESOR DE AIRE GASOLINA

(SEGUNDA ETAPA)

1. Calcomanía- Advertencia: Supercies

Calientes

2. Calcomanía- Advertencia: Caliente

3. Motor

4. Interruptor de motor

5. Control de regulador de motor

6. Válvula de piloto

7. Puerto de relleno del aceite de la

bomba

8. Varilla del aceite

9. Sumidero del aceite

10. Calcomanía- Advertencia: Calientes

11. Calcomanía- Peligro / Advertencia /

Precaución

12. Válvula de alivio de presión

13. Vávula (s) de descargar del tanque de

aire

14. Indicador de presión de tanque de aire

15. Indicador de presión de tanque de aire

16. Regulador de presión

17. Abiertas de ventilación

18. Bomba de compresor de aire

19. Filtro de aire

20. Calcomanía- Advertencia: Guardia del

cintúron está en lugar.

21. Calcomanía- Advertencia: Riesgo de

lesiones

22. Guardia del cintúron

AC2-PH08-PV09-20-FEATURE-012704-DLG AC2-PH08-PV09-FEATURES-012704-DLG

AS2-PH08-PR09-PV09-08 FEATURES-012704-DLG

AM2-SH09-B-FEATURE-01809-RSW

Mi-T-M

Manual de operador de compresor de aire gasolina. 29

BOMBA DE COMPRESOR DE AIRE: Una bomba de compresor de dos estapas usa

cilindros de dos tamaños diferentes con la válvula entrada de el más pequeño y se-

gundo cilindro que unir cilindro. En el tiempo abajo aire sea retraido por las válvulas

entradas mientras las válvulas de exhausto quedan cerrado. En el tiempo arriba el

aire sea comprimido las válvulas entradas cierran y aire comprimido sea forzados

por las válvulas de exhausto entre el entre frigerante y por la válvula entrada de el

más pequeno y segundo cilindro en el tiempo abajo. En el tiempo arriba del cilindro

pequeno, la válvula entrada cierra y aire comprimido comprimir un tiempo segundo y

forzad afuera de válvula de exhausto entre la linea de deposito por válvula de revisar

de tanque y entre el tanque de aire.

VISTA EXPLOTADA & EXPLICACIÓN DE ELEMENTOS DE COMPRESOR DE AIRE

VÁLVULA DE ALIVIO DE SEGURIDAD: Esta válvula sea diseñado para prevenir falla de

la sistema por aliviando alcance un nivel predeterminado. La válvula ha preprogramado

por el fabricante y no puede modicar en ninguna manera. Para vericar que la válvula

está trabajando correctamente, tire en el anillo. Presión de aire debe escapar. Cuando

el anillo sea liberado, lo volver a cero.

VÁLVULA DE PILOTO: Cuando el muletilla está en posición vertical, todo el aire de

compresor de aire descargó por el moe de depósito. Este da un elemento de empezar

fácil. Para operación normal, la muletilla está en posición de 90°.