SINK SPECIFICATIONS
Glass Vessel Sink
Model VG07053
MODEL # SINK SINK HOLE
DIAMETER HEIGHT DIAMETER
VG07053 16 1/2" 5 1/2" 1 3/4"
DIMENSIONS
MODEL VG07053
FEATURES
PACKING LIST
5 1/2"
16 1/2"
TOLL FREE: (866) 591 - 7792
E-Mail: [email protected]
www.vigoindustries.com
For warranty purposes contact our toll free number:
5 1/2"
MODEL VG07053
THE MEASUREMENTS IN INCHES ARE ROUNDED TO THE NEAREST 1/8"
TOP VIEW
FRONT VIEW
16 1/2"
NOTE:
1 3/4"
GLASS THICKNESS 1/2"
GLASS DIAMETER AND HEIGHT MAY VARY UP TO 1/ 2"
2
3
To ensure that your installation project goes smoothly, please review these
instructions before proceeding.
Your new lavatory is designed for years of trouble-free performance.
Keep it looking new by cleaning it periodically with a soft cloth. Avoid abrasive
cleaners, steel wool and harsh chemicals.
MAINTENANCE
ASSEMBLY
REQUIRED TOOLS
Plumber's putty or Caulk
Caulking Gun
Tape Measure
SAFETY TIPS
Observe all local plumbing and building codes.
Risk of personal injury or product damage. Handle with care. Glass can break or
chip if the product is handled carelessly.
Prior to installation, unpack the new lavatory and inspect it for damage. Return the
lavatory to its protective carton until you are ready to install it.
IMPORTANT POINTS
1. Installation must be done by a qualified, licensed plumber. The contractor must
perform a dry fit prior to drilling holes in the counter top for the sink.
3. All Vigo vessel bowls are hand made. You may expect variations in color,
texture and bowl symmetry. If you notice any obvious variation or defects you
should contact your retailer immediately.
4. Vessel sinks are extremely durable and can withstand a temperature change
5. Though resistant to breakage, vessel sinks can break or chip when a heavy
object falls in or on them.
INSTALLATION
Installation must be done by a qualified licensed plumber.
Prior to installation please read the instructions thoroughly, confirm that all parts
are included and visually inspect the unit for any defects.
If you have any questions please contact the Vigo Technical Support
Department before proceeding with installation.
PACKAGE CONTENTS
ONLY THE SINK IS PROVIDED
Make sure to use the intended style drain / pop-up. The Vigo style vessel bowl
does not have an overflow. Therefore the drain / pop-up needs to
correspond appropriately.
LAVATORY
Turn off the water supply. This is done by closing the two shut-off valves
located under the lavatory. If there are no shut-off valves leading to the lavatory,
you must turn off the water at the main valve. This is usually located in the
basement, garage or near the foundation on the outside of the house. It may
also be near the water meter. Check to be sure the water is off by turning on
the faucet where you are working until the water stops flowing. If you have shut
off the main valve in a two-story house or greater, you should open the kitchen
faucet and another faucet on the same level. Water will then drain from the
entire line. This will help avoid spills. Be sure and close the faucets before you
turn on the main valve again. Disconnect the drain pipes. Take off as many
sections as possible between the lavatory and the wall or floor to facilitate
removal. Place a basin under the work area to catch any water that may still be
in the drain.
REMOVING YOUR OLD LAVATORY
NOT PROVIDED
TAIL PIECE
DRAIN NUT
TO DRAIN
WASHER
DRAIN ASSEMBLY
SOFT WHITE WASHER
STAND
RUBBER STAND WASHER
POP UP TOP
INTERNAL BRASS PIECE (POP UP MECHANISM)
1. Please inspect your working surface, making sure it is level and clean.
2. Determine the layout for the sink you desire. It is important to fully "dry" position
the sink with your faucet purchase on the countertop. Things to include, but are not
limited to;
desired position.
4. The sink can be mounted to the countertop with or without a stand. It is highly
recommended that the customer utilize the stand. This will allow for proper
cleaning around the exterior of the bowl and will make sure that there is no direct
contact between your bowl and desired countertop. The stand is an optional
purchase and is not included in with the purchase of the vessel bowl. Note: The
stand comes as a free accessory with a Vigo style pop up. If you decide not to
purchase the Vigo style pop up, the stand can be purchased through the Vigo
technical support department.
5. If a stand is not purchased it is advised to apply a bead of caulk between the
bottom of the sink and the countertop. This will prevent movement and ease the
leveling process.
DO NOT OVER TIGHTEN THE DRAIN
!
STAND
RUBBER WASHER
STAND
BLACK RUBBER WASHER
STAND
POP UP DRAIN
RUBBER WASHER
TAIL PIECE
DRAIN NUT
SOFT WHITE WASHER
STAND
RUBBER STAND WASHER
POP UP DRAIN TOP
RUBBER WASHER
SINK
BLACK RUBBER WASHER
COUNTERTOP
TAIL PIECE NUT
COUNTERTOP
INTERNAL BRASS PIECE
(POP UP MECHANISM)
TOP VIEW
BOTTOM VIEW
(with stand installed)
WHITE PLASTIC WASHER
WHITE PLASTIC WASHER
4
GLASS SINK LIMITED LIFETIME WARRANTY
EFFECTIVE JANUARY 1, 2010
household use. For commercial uses, additional limitations apply.
VIGO warrants the Product to be free from defects in workmanship and materials under normal use and service for the period commencing from the initial date of
purchase by the owner or end-user, contractor, or builder, from VIGO or an authorized VIGO dealer, through the lifetime of the original owner or end-user.
Subject to the Warranty Service provision below, any product reported to the authorized dealer or to VIGO as being defective within the warranty period will be repaired
or replaced (with a product of equal value) at the option of VIGO. This warranty extends to the original owner or end-user and is not transferable to a subsequent owner.
Neither the distributor, authorized VIGO dealer, nor any other person has been authorized to make any affirmation, representation, or warranty other than those
contained in this warranty. Any affirmation, representation, or warranty other than those contained in this warranty shall not be enforceable against VIGO or any other
person.
VIGO reserves the right to modify this warranty at any time, it being understood that such modifications will not alter the warranty conditions applicable at the time of
sale of the products in question.
Limitations
This warranty shall not apply to instances of incorrect operating procedures, breakages, or damages caused by fault through improper installation, carelessness, abuse,
misuse, misapplication, improper maintenance, or alteration of the Product, as well as chemical or natural corrosion, accident, fire, flood, an act of God, or any other
casualty. Avoid abrasive cleaners, steel wools, and harsh chemicals as these will scratch, damage, and / or dull the product and / or finish and void this warranty. The
owner/end-user of the Product covered by the present warranty is entirely responsible for its proper installation and any applicable plumbing or electrical wiring. VIGO
neither installs nor supervises the installation nor hires a contractor for this purpose; consequently, VIGO cannot be held responsible for any default, breakage, or
damages caused thereby or resulting thereof, either directly or indirectly.
The owner/end-user must provide access to the components of the Product as described in the installation guide so that VIGO can execute the warranty specified
herein. If such access is not available, all expenses to provide said access will be the responsibility of the owner/end-user.
This warranty does not apply to Products that have not been installed or operated in accordance with instructions supplied by VIGO and all applicable rules, regulations,
and legislation pertaining to such installations.
This warranty does not apply unless the VIGO Product is installed by fully insured licensed professionals. Vigo strongly recommends that such licensed professionals
have experience in the installation of bathroom and kitchen products. Installation of certain products, including, without limitation, glass products (i.e., shower doors and
glass sinks) by an inexperienced person may result in glass breakage and, consequently, cause personal injury or death.
VIGO is not liable for personal injuries or deaths to any persons or for any direct, special, incidental, or consequential damage, loss of time, loss of profits,
inconvenience, incidental expenses, labor or material charges, or any other costs resulting from the use of the product or equipment or pertaining to the application of
the present warranty, or resulting from the removal or replacement of any product or element or part covered by this warranty.
EXCEPT AS OTHERWISE PROVIDED ABOVE, VIGO MAKES NO WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY
AND FITNESS FOR A PARTICULAR PURPOSE OR COMPLIANCE WITH ANY CODE.
In any case, VIGO cannot be held liable for any amount over and above the purchase price paid for the Product by the owner/end-user, contractor, or builder.
Commercial Limitations
In addition to the above conditions and limitations, the warranty period for products installed for commercial applications or used in commercial ventures is one (1) year
from the initial date of purchase by the owner/end-user, contractor, or builder from an authorized dealer. VIGO is not responsible for loss of use or profit under any
circumstances. If the product is used as a display, the warranty period begins when the product is placed on display. This warranty gives the owner/end-user specific
legal rights. The owner/end-user may also have other rights which can vary from one state or province to another.
Warranty Service
In order to obtain service provided under this warranty during regular business hours, contact the dealer or distributor who sold the unit, or contact VIGO directly. VIGO
will provide the warranty service described above when the following conditions have been met: the failure is of the nature or type covered by the warranty; the user has
(e.g., proof of purchase or installation) is provided to the foregoing by the user proving that the failure occurred or was discovered within the warranty period; an
authorized independent service person or company representative has been permitted to inspect the product during regular business hours within a reasonable time
*Certain models are pending approval.
Certification may be ended by VIGO or certification agencies without notice.
Lavabo en verre
DU LAVABO DU LAVABO DE L'ORIFICE
VG07053 16 1/2" 5 1/2" 1 3/4"
DIMENSIONS
LISTE DES ARTICLES
5 1/2"
16 1/2"
www.vigoindustries.com
Pour toute question concernant la garantie, composez
5 1/2"
VUE DE DESSUS
VUE DE FACE
16 1/2"
1 3/4"
2
3
chimiques puissants.
ENTRETIEN
ASSEMBLAGE
Mastic ou calfeutrage de plombier
Vous risqueriez de vous blesser ou d'endommager le produit. Manipulez le
produit en douceur En cas de manipulation brusque, il peut arriver que le verre
POINTS IMPORTANTS
1. .
dans le comptoir pour installer le lavabo.
INSTALLATION
Si vous avez des questions, appelez le service de soutien technique de Vigo
CONTENU DE L'EMBALLAGE
SEUL LE LAVABO EST FOURNI
LAVABO
possibles entre le lavabo et le mur ou le sol. Placez une bassine sous la zone
et propre.
dans la position voulue.
de Vigo.
NON INCLUS
VERS LE DRAIN
RONDELLE
ENSEMBLE
EN CAOUTCHOUC
DESSUS DE LA BONDE
NE SERREZ PAS TROP LE DRAIN
!
RONDELLE DE
RONDELLE EN
DRAIN DE LA BONDE
RONDELLE DE
DESSUS DU DRAIN DE LA BONDE
RONDELLE DE CAOUTCHOUC
LAVABO
RONDELLE EN
COMPTOIR
COMPTOIR
VUE DE DESSUS
VUE DE DESSOUS
PLASTIQUE BLANCHE
BLANCHE
SOUPLE
DE DRAIN
RACCORDEMENT
RONDELLE
RONDELLE EN
DE RACCORDEMENT
PLASTIQUE BLANCHE
RONDELLE SOUPLE
BLANCHE
CAOUTCHOUC NOIRE
EN CAOUTCHOUC
CAOUTCHOUC
DE DRAIN
RONDELLE EN
CAOUTCHOUC
CAOUTCHOUC NOIRE
4
VIGO INDUSTRIES, LLC ("VIGO")
ou utilisateur final en vue d'un usage personnel domestique. D'autres limitations s'appliquent en cas d'usage commercial.
l'entrepreneur ou le constructeur.
Limitations
l'installation de certains produits, y compris sans toutefois s'y limiter, les produits en verre (portes de douches et lavabos en verre) sont susceptibles de les briser et, par
SAUF DISPOSITION CONTRAIRE CI-DESSUS, VIGO NE FAIT AUCUNE GARANTIE, EXPRESSE OU IMPLICITE, Y COMPRIS DE VALEUR MARCHANDE,
le constructeur.
Limitations commerciales
Service de garantie
ESPECIFICACIONES DEL LAVABO
Lavabo de vidrio
Modelo VG07053
MODEL LAVABO ORIFICIO DEL LAVABO
NRO.
VG07053 16 1/2" 5 1/2" 1 3/4"
DIMENSIONES
MODELO VG07053
CONTENIDOS DEL PAQUETE
5 1/2"
16 1/2"
www.vigoindustries.com
5 1/2"
MODELO VG07053
VISTA SUPERIOR
VISTA FRONTAL
16 1/2"
1 3/4"
GROSOR DEL VIDRIO 1/2"
2
3
instrucciones antes de instalarlo.
inconvenientes.
fuertes.
MANTENIMIENTO
MONTAJE
HERRAMIENTAS NECESARIAS
Pistola para calafatear
CONSEJOS DE SEGURIDAD
instalarlo.
PUNTOS IMPORTANTES
1. El
contratista debe posicionarlo en seco antes de hacer los orificios en la parte superior
de la encimera.
4. Los lavabos son muy duraderos y pueden soportar cambios de temperatura de
5. Si bien son resistentes a roturas, los lavabos pueden quebrarse o picarse cuando
caen objetos pesados dentro de ellos o sobre ellos.
para ver si tiene defectos.
CONTENIDO DEL PAQUETE
de estilo Vigo no cuentan con vertedero de superficie. Por lo tanto, el
LAVABO
tantas secciones como sea posible entre el lavabo y la pared o el piso para facilitar
nivelada y limpia.
posicionar el lavabo por completo "en seco" con el grifo comprado en la encimera.
Alguna de las cosas a considerar, entre otras:
4. El lavabo puede montarse sobre la encimera con o sin pie. Se recomienda en
5. Si no lo compra, se recomienda aplicar un reborde de calafate entre la parte
TUERCA DE
ARANDELA BLANCA
PIE
ARANDELA DE CAUCHO DEL PIE
PARTE SUPERIOR DEL
ARANDELA BLANCA DE CAUCHO
LAVABO
ENCIMERA
PIEZA INTERNA DE BRONCE
(MECANISMO DE
ARANDELA DE CAUCHO
NOTA: LA BATALLA ES OPCIONAL
NO INCLUIDO
ARANDELA
ARANDELA BLANCA BLANDA
PIE
ARANDELA DE CAUCHO DEL PIE
PARTE SUPERIOR DEL
PIEZA INTERNA DE BRONCE
!
PIE
ARANDELA
PIE
ARANDELA NEGRA DE CAUCHO
PIE
ARANDELA DE CAUCHO
ARANDELA NEGRA DE CAUCHO
ENCIMERA
VISTA SUPERIOR
VISTA DE FONDO
(con pie instalado)
DE CAUCHO
BLANDA
4
VIGO INDUSTRIES, LLC ("VIGO")
fecha de compra inicial por parte del propietario/ usuario final, contratista o constructor a VIGO o a un distribuidor autorizado de VIGO y durante toda la vida del
propietario o usuario final originales.
otras personas.
Limitaciones
final.
incluidos, entre otros, productos de vidrio (es decir, puertas de duchas y lavabos de vidrio) por parte de personas sin experiencia puede provocar ruptura del vidrio y,
por ende, lesiones personales o la muerte.
abonaran por el Producto.
Limitaciones comerciales
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
