Vigo VG15124 Guía de instalación

Marca: Vigo

Modelo: VG15124

Tipo: Guía de instalación

SINK SPECIFICATIONS

SINGLE BOWL Farmhouse

Model VG3320C

MODEL # BOWL SIZE SINK DEPTH EXTERIOR GAUGE

VG3320C 9 7/8" 16

31" x 18"

DIM.

NOMINAL DIMENSIONS

TOP VIEW

FRONT VIEW

33" [838mm]

31" [788mm]

22 1/4" [566mm]

33" x 22 1/4"

FEATURED MODEL VG3320C

9 7/8" BOWL DEPTH

FEATURES

 16 gauge, stainless steel

 304 Nickel - Bearing Content

 Zero radius corners

 Elegant and functional drain grooves

 Long-lasting, easy-to-clean, satin finish

 Sound-deadening insulation

 Rear drain placement

 Round apron front

PACKING LIST

- SINK

10" [255mm]

21 1/2" [546mm]

9 1/16"

[230mm]

9 7/8"

[250mm]

18" [457mm]





NOTE: THESE SINKS ARE INTENDED FOR

INDOOR KITCHEN USE ONLY. THEY ARE NOT

RATED FOR OUTDOOR USE. INSTALLATION OF

THIS SINK IN AN OUTDOOR SETTING WILL VOID

ANY WARRANTY ON THIS PRODUCT.

General Recommendations:

Read installation and maintenance instructions thoroughly before installation. Inspect your sink for any

noticeable damage before installation. Check all local applicable plumbing and building codes.

These instructions are based on application to composite material or solid surface countertop

installation only; countertop application to stone, marble, granite or butcher-block should be referred to

experienced countertop fabricator for custom installation.

Vigo Farmhouse series sinks are individually hand-crafted and Vigo suggests using experienced and

professional installers only. For custom cutting of countertop and installation of the actual sink, on-site

installation is also recommended. Acceptable variances are approximately 1/2 of an inch. Alignment to

cut-out and precise application and trimming of any adhesive sealant are critical to a superior fit and

finished look. Please take extra care in this regard.

Vigo Farmhouse series sinks require custom order cabinets. Consult your cabinet dealer.

Vigo does not accept any liability for damage to countertop, sink fixture, faucets or personal injury

during installation. Warranty is void if installation instructions are not followed.

Tools and Materials needed:

Tape Measure Denatured Alcohol Wood Braces

Pencil (NOT ink) Ear Protection Framing Square

Silicone Adhesive Sealant Eye Protection Shims

Rags Hacksaw/Jigsaw

Be sure to use proper tools and always wear personal safety accessories for your protection.

Installation instructions Farmhouse Sinks

Installation Options:

Vigo Farmhouse series sinks offer installation options depending on your design.

Figure 1 Figure 2

Caution: All installation types need to allow room for faucet installation. Ensure adequate clearance

behind the sink for any faucet and backsplash, as well as full range of motion for faucet spouts and

handles.

Typical undermount installation with 1/4" reveal recommended.

Typical flush mount and above counter installation

Above counter installation may expose sink sides to be raised above the countertop.

Undermount Installation

Flush mount Installation

Above counter Installation

Figure 3

Figure 4

Figure 6

Figure 5

Figure 7

Contact your retailer if any product is damaged or missing prior to installation. Never install a

damaged sink as it can void your warranty.

Typical

Sink Profile

Finished Wall

from

countertop

front end

Sink Front End

Cabinet

Front Line

Typical

Sink Profile

Finished Wall

from

countertop

front end

Sink Front End

Cabinet

Front Line

1. Prepare the sink base cabinet

Farmhouse sinks require custom order sink base cabinets with a

front cutout to accommodate a 10" deep sink. Build structural

supports on the inside frame of the sink base cabinet. The

structural supports must support the weight of the sink and any

attachments such as garbage disposals. When the sink is placed

onto the cabinet support, make sure the top of the sink is evenly

flush against the bottom of the countertop. Allow clearance for

water supply line and drains or garbage disposal, as necessary.

2. Make template and cutout

Depending on the installation option, make proper cutout of the

countertop. Vigo recommends a 1/4" reveal on 3 sides when

installed undermount style. For a flush mount or above counter

installation, cut countertop along with outside of sink profile. Front

end of Vigo Farmhouse sinks are designed to be installed 3/4"

extended out beyond the front end of the countertop. Cut

countertop accordingly. No template is provided due to the custom

nature of each application and installation. The actual sink is used

as the template guide for each installation. After centering the sink

and allowing for faucets and backsplashes, use a pencil to outline

the sinks as your guide for the cutout, allowing for any reveal

before the actual cutting.

3. Set the sink

Set the sink on top of the cabinet or into the cabinet front cutout.

Apply sealant if necessary as a gasket between the sink and

cabinet.

4. Install the countertop

Carefully clean bottom of countertop and top flange of sink with

denatured alcohol. Apply bead of silicone adhesive (not supplied)

around the top edge of the sink. Place countertop onto the sink.

Remove excess sealant from the lip of any surfaces with a cleaner

recommended by manufacture of adhesive sealant.

Care and Maintenance

ALWAYS





preventative cleaning.



affect the appearance of your sink.



abrasive such as Comet.



up over time with a mild solution of vinegar and water followed by a thorough flushing with water.



grain. NOT RECOMMENDED FOR MIRROR FINISH.

NEVER



develop rust spots in the stainless steel surface.





finish of your sink.



the finish of your sink.



sink. Silver cleaners can also contain acids that will damage the sink surface.





KITCHEN SINK LIMITED LIFETIME WARRANTY

EFFECTIVE JANUARY 1, 2010



end-user for personal household use. For commercial uses, additional limitations apply.

VIGO warrants the Product to be free from defects in workmanship and materials under normal use and service for the period commencing from

the initial date of purchase by the owner or end-user, contractor, or builder, from VIGO or an authorized VIGO dealer, through the lifetime of the

original owner or end-user.

Subject to the Warranty Service provision below, any product reported to the authorized dealer or to VIGO as being defective within the warranty

period will be repaired or replaced (with a product of equal value) at the option of VIGO. This warranty extends to the original owner or end-user

and is not transferable to a subsequent owner.

Neither the distributor, authorized VIGO dealer, nor any other person has been authorized to make any affirmation, representation, or warranty

other than those contained in this warranty. Any affirmation, representation, or warranty other than those contained in this warranty shall not be

enforceable against VIGO or any other person.

VIGO reserves the right to modify this warranty at any time, it being understood that such modifications will not alter the warranty conditions

applicable at the time of sale of the products in question.

Limitations

This warranty shall not apply to instances of incorrect operating procedures, breakages, or damages caused by fault through improper installation,

carelessness, abuse, misuse, misapplication, improper maintenance, or alteration of the Product, as well as chemical or natural corrosion,

accident, fire, flood, an act of God, or any other casualty. Avoid abrasive cleaners, steel wools, and harsh chemicals as these will scratch,

damage, and / or dull the product and / or finish and void this warranty. The owner/end-user of the Product covered by the present warranty is

entirely responsible for its proper installation and any applicable plumbing or electrical wiring. VIGO neither installs nor supervises the installation

nor hires a contractor for this purpose; consequently, VIGO cannot be held responsible for any default, breakage, or damages caused thereby or

resulting thereof, either directly or indirectly.

The owner/end-user must provide access to the components of the Product as described in the installation guide so that VIGO can execute the

warranty specified herein. If such access is not available, all expenses to provide said access will be the responsibility of the owner/end-user.

This warranty does not apply to Products that have not been installed or operated in accordance with instructions supplied by VIGO and all

applicable rules, regulations, and legislation pertaining to such installations.

This warranty does not apply unless the VIGO Product is installed by fully insured licensed professionals. Vigo strongly recommends that such

licensed professionals have experience in the installation of bathroom and kitchen products. Installation of certain products, including, without

limitation, glass products (i.e., shower doors and glass sinks) by an inexperienced person may result in glass breakage and, consequently, cause

personal injury or death.

VIGO is not liable for personal injuries or deaths to any persons or for any direct, special, incidental, or consequential damage, loss of time, loss of

profits, inconvenience, incidental expenses, labor or material charges, or any other costs resulting from the use of the product or equipment or

pertaining to the application of the present warranty, or resulting from the removal or replacement of any product or element or part covered by

this warranty.

EXCEPT AS OTHERWISE PROVIDED ABOVE, VIGO MAKES NO WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF

MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE OR COMPLIANCE WITH ANY CODE.

In any case, VIGO cannot be held liable for any amount over and above the purchase price paid for the Product by the owner/end-user,

contractor, or builder.

Commercial Limitations

In addition to the above conditions and limitations, the warranty period for products installed for commercial applications or used in commercial

ventures is one (1) year from the initial date of purchase by the owner/end-user, contractor, or builder from an authorized dealer. VIGO is not

responsible for loss of use or profit under any circumstances. If the product is used as a display, the warranty period begins when the product is

placed on display. This warranty gives the owner/end-user specific legal rights. The owner/end-user may also have other rights which can vary

from one state or province to another.

Warranty Service

In order to obtain service provided under this warranty during regular business hours, contact the dealer or distributor who sold the unit, or contact

VIGO directly. VIGO will provide the warranty service described above when the following conditions have been met: the failure is of the nature or



nature of the problem during the warranty period; conclusive evidence (e.g., proof of purchase or installation) is provided to the foregoing by the

user proving that the failure occurred or was discovered within the warranty period; an authorized independent service person or company

representative has been permitted to inspect the product during regular business hours within a reasonable time after the problem was reported





*Certain models are pending approval.

Certification may be ended by VIGO or certification agencies without notice.





 VG3320C





VG3320C 9 7/8" 16

31" x 18"

DIMENSIONS NOMINALES

VUE DE DESSUS

VUE DE FACE

33" [838mm]

31" [788mm]

22 1/4" [566mm]

33" x 22 1/4"

LISTE DES ARTICLES

- 

10" [255mm]

21 1/2" [546mm]

9 1/16"

[230mm]

9 7/8"

[250mm]

18" [457mm]







 Acier inoxydable de calibre 16

 Contenant du nickel 304

 

 

 

 Isolation sonore

 

 Avant du tablier arrondi

 VG3320C





INDOOR UTILISATION DE CUISINE SEULEMENT. ILS





NATUREL ANNULE AUCUNE GARANTIE SUR CE

PRODUIT.











ayant une surface solide. La pose de comptoir sur des blocs de boucher, du granite, du marbre ou de



















revendeur d'armoires.



des robinets, ni des blessures physiques lors de l'installation. La garantie s'annule si les instructions





  Attaches pour bois

Crayon (PAS d'encre) Protection pour les oreilles 

 Protection pour les yeux Cales

Chiffons Scie/Scie sauteuse











voulu.

Figure 1 Figure 2

















Installation avec



Installation sur un comptoir

Figure 3

Figure 4

Figure 6

Figure 5

Figure 7





Typique



Mur fini





avant

du comptoir



Armoire

Ligne avant

Typique



Mur fini





avant

du comptoir



Armoire

Ligne avant

1. 





de 10''. Construisez des supports de structure sur le cadre













2. 



au comptoir. Vigo recommande de laisser un rebord de 1/4'' sur



















suffisamment d'espace pour les robinets et les jets d'eau, utilisez







3. 







4. Installez le comptoir















Entretien

TOUJOURS



et essuyez-le bien.











produit abrasif doux (Comet, par exemple).





vinaigre et d'eau, puis rincez minutieusement avec de l'eau.





JAMAIS





en acier inoxydable.























VIGO INDUSTRIES, LLC ("VIGO")





utilisateur final en vue d'un usage personnel domestique. D'autres limitations s'appliquent en cas d'usage commercial.





constructeur.











tiers.





Limitations













directement ou indirectement.















blessures, voire la mort.













constructeur.

Limitations commerciales









Service de garantie













proposition par le client met fin aux obligations de VIGO au titre de la garantie.





ESPECIFICACIONES DEL LAVABO

TO

Modelo VG3320C

VG3320C 9 7/8" 16

31" x 18"

VISTA SUPERIOR

VISTA FRONTAL

33" [838mm]

31" [788mm]

22 1/4" [566mm]

33" x 22 1/4"

MODELO DESTACADO VG3320C





 16 de ancho, acero inoxidable

 

 Esquinas de radio cero

 

 

 Aislamiento insonorizante

 

 Revestimiento redondeado delantero

CONTENIDOS DEL PAQUETE

 FREGADERO

10" [255mm]

21 1/2" [546mm]

9 1/16"

[230mm]

9 7/8"

[250mm]

18" [457mm]





DIMENSIONES NOMINALES

MODELO  PROFUNDIDAD

NRO. DE TAZON DEL FREGADERO EXTERIOR DIM. ANCHO

NOTA: 

PARA USO DE COCINA EN INTERIORES. NO SON



FREGADERO EN UN ESCENARIO AL AIRE LIBRE



PRODUCTO.

Recomendaciones generales:















coloquen instaladores profesionales y con experiencia. Para realizar cortes e instalaciones especiales









aspecto.



distribuidor de armarios.







Herramientas y Materiales necesarios:

 Alcohol Desnaturalizado Abrazaderas para madera

 

Sellador adhesivo de silicona 

Trapos 



para protegerse.







Figura 1 Figura 2





como para el movimiento completo de la boca del grifo y sus llaves.







encimera.







del fregadero

Figura 3

Figura 4

Figura 6

Figura 5

Figura 7







Pared terminada

desde

el extremo

delantero de

la encimera

Extremo delantero del fregadero



delantera

del armario

Perfil del fregadero

desde

el extremo

delantero de

la encimera

1. 



especial con un corte delantero para fregaderos de 10" de

profundidad. Construya apoyos estructurales en el bastidor

interior del armario de la base del fregadero. Los apoyos

estructurales deben sostener el peso del fregadero y todos sus





el embutido de su parte superior contra el fondo de la encimera





2. Plantilla y corte







instalaciones embutidas, corte la encimera a lo largo del exterior





delantero sobresalga 3/4" del extremo delantero de la encimera.













hacer el corte real.

3. 

Coloque el fregadero sobre el armario o dentro del corte delantero



entre el fregadero y el armario.

4. 

Limpie con cuidado la encimara y el reborde superior del

fregadero con alcohol desnaturalizado. Aplique un reborde de

adhesivo de silicona (no incluido) alrededor del borde superior del

fregadero. Una la encimera al fregadero. Con un limpiador que

recomiende el fabricante del sellador adhesivo, elimine el exceso

de sellador del borde de las superficies.

Cuidado y Mantenimiento

SIEMPRE





mayor limpieza preventiva.



minerales que pueden afectar su aspecto.











RECOMIENDA HACERLO EN ACABADOS BRILLANTES. NUNCA









pues puede arruinar el acabado.



demasiado largo pues pueden arruinar el acabado.





fregadero.



VIGO INDUSTRIES, LLC ("VIGO")











la fecha de compra inicial por parte del propietario/ usuario final, contratista o constructor a VIGO o a un distribuidor autorizado de VIGO y durante toda la vida del

propietario o usuario final originales.











otras personas.





Limitaciones













indirecta.





propietario/usuario final.









incluidos, entre otros, productos de vidrio (es decir, puertas de duchas y lavabos de vidrio) por parte de personas sin experiencia puede provocar ruptura del vidrio y,

por ende, lesiones personales o la muerte.















abonaran por el Producto.

Limitaciones comerciales

































