Vigo VG05005BN Manual de usuario

Marca: Vigo

Modelo: VG05005BN

Categoría: Artículos sanitarios

Tipo: Manual de usuario

FAUCET SPECIFICATIONS

Wall Mount Bathroom Faucet

Model VG05005

MODEL # FAUCET SPOUT

HEIGHT REACH

VG05005 5 1/8" 6 5/8"

DIMENSIONS

MODEL VG05005

FEATURES

Solid brass construction

Ceramic disk cartridge

Single lever faucet

Wall mount installation

Finish resist corrosion and tarnishing

PACKING LIST

Faucet Assembly

Allen Key

Spout

Cover for spout

Mixer

Handle

Cover for handle

Washer

NOTE: All faucets are compliant to CEC 2016 regulations. If you

have inquiries about your water flow, please email

[email protected].

6 5/8"

5 1/8"

THE MEASUREMENTS IN INCHES ARE ROUNDED TO THE NEAREST 1/8"

VG05005

SIDE VIEW

FRONT VIEW

3 3/8" 3 3/8"

3 3/8"

1 5/8"

5 1/4"

5 1/8"

15/8"

6 5/8"

This product meets the CEC requirements. It is up to the discretion of the client to modify the product with the

provided restrictor. Doing so will remove the ability for the product to meet certain low flow standards. Please talk to

your local or statewide plumbing enforcement agency prior to modifying. Vigo is not responsible for any alterations

and the affects that may come with altering the product post sale and highly advises that the client only install the

product that meets the needs of their local plumbing code.

Flow rate with installed restrictor (pink) - 1.2 gpm

Flow rate with restrictor provided in box (orange) - 1.5 gpm

FLOW RATE REGULATIONS

Loosen the two set screws at the bottom of the spout. Pull

the spout off of the faucet. Pull the spout plate away from

the wall.

Unscrew and remove the brass connector with the pink 1.2

gpm restrictor inside.

Replace with the brass connector with the orange 1.5 gpm restrictor

inside by screwing it back in. Replace the spout plate and spout by

tightening the two set screws at the bottom of the spout.

Brass connector

Spout plate

Brass connector

Installation must be done by a qualified licensed plumber.

Prior to installation please read the instructions thoroughly, confirm that all

parts are included and visually inspect the unit for any defects.

If you have any questions please contact the Vigo Technical Support

Department before proceeding with installation.

2. CONNECT PIPES WITH COLD AND HOT WATER TO THE

MIXER USING TEFLON TAPE.

3. SECURE MIXER TO THE WALL.

4. CONNECT SPOUT TO THE MIXER USING THE SUPPLIED WASHER.

SECURE WASHER BEHIND THE THREADED PORTION

OF THE SPOUT FOR SPACING. THREAD THE SPOUT SO THE

TIP FACES DOWN MAKING SURE NOT TO OVER TIGHTEN THE SPOUT TO

THE MIXER.

NOT INCLUDED.

PLEASE CONSULT

A QUALIFIED

LICENSED

PLUMBER.

Your new faucet is designed for years of trouble-free performance.

Keep it looking new by cleaning it periodically with a soft cloth. Avoid abrasive

cleaners, steel wool and

harsh chemicals as these will scratch, dull, and/or damage the finish and/or product

void your warranty.

Be sure to shut off water supply prior to installation.

Protect your eyes with safety glasses when cutting or soldering water

supply lines

Cover your drain to avoid losing parts.

Prior to beginning installation, turn off the cold and hot water lines and open the hot

and cold knobs on the old faucet to release build-up pressure.

When installing your new faucet, turn the connector nuts finger-tight, then use one

wrench to anchor the fitting and a second wrench to tighten the nut one additional

turn. Connections that are too tight will reduce the integrity of the system.

Wrap all threaded connections with Teflon tape available at your local hardware or

plumbing supply store. Always wrap in a clockwise direction.

All installations can vary depending on how your previous faucet was installed. Not

all necessary supplies to install your faucet are included, however, they are

available wherever plumbing supplies are sold.

Adjustable wrench

Groove joint pliers

Plumber's putty

Pipe tape

Phillips and flat screwdrivers

5. ATTACH HANDLE.

COLD

WATER

SPOUT

HOT WATER

HANDLE

WASHER

MAINTENANCE

REQUIRED TOOLS

IMPORTANT POINTS

SAFETY TIPS

INSTALLATION

ASSEMBLY

PACKAGE CONTENTS

1. SHUT OFF WATER SUPPLY.

REMOVE THE OLD FAUCET AND

FLEXIBLE HOSES. CLEAN SINK

SURFACE IN PREPARATION FOR

THE NEW FAUCET. FLUSH WATER

CONNECTION AT HOME TO MAKE

SURE NO DEBRIS IS STUCK IN

THE LINE.

6. AFTER INSTALLATION IS COMPLETE TURN ON

THE WATER SUPPLY VALVES AND ALLOW BOTH

HOT AND COLD WATER TO RUN AT LEAST ONE

MINUTE EACH. WHILE WATER IS RUNNING,

CHECK FOR LEAKS, ESPECIALLY AT HOOK-UPS

TO SUPPLY LINES. TIGHTENING NUTS SLIGHTLY

WILL STOP ANY MINOR LEAKS.

PART

PART #

FINISH

SUPPLY DATE INDICATOR (INTERNAL USE ONLY)

PARTS LIST - For any parts needed but not shown, please contact Vigo Technical Support

TOLL FREE: (866) 591 - 7792

E-Mail: [email protected]

www.vigoindustries.com

NSF / ANSI 61

TROUBLESHOOTING

PROBLEM POTENTIAL CAUSE CORRECTIVE ACTION

1 - Leaks from handle

2 - Insufficient flow rate

3 - Leak at connection points

4 - Loose faucet body

1.A - Cartridge unseated

1.B - Cartridge defective

2.A - Dirty aerator

2.B - Clog in supply hose / line

3.A - Flexible hose leaking at connection point

3.B - Washer defective

4. - Mounting hardware became loose

3.A - Tighten hoses. If this does not resolve the issue, remove

the flexible hose and rethread, checking to make sure the

connection is secure. Make sure to use pipe tape.

2.B - Remove supply lines and flush lines.

2.A - Remove aerator and soak / clean with a non abrasive

agent (i.e. half hot water and half vinegar).

1.B - Contact Vigo Technical Support for replacement.

1.A - Remove cartridge from housing, wash thoroughly with hot

water and reseat in housing.

3.B - Remove supply line and check the status of the washer. If

torn, washer must be replaced for a secure, non-leaking

connection.

4. - From under the counter, use an adjustable wrench and

tighten the mounting hardware. Make sure the faucet is

perpendicular to the counter.

5 - Loose handle

5. - Set screw has become loose

5. - Take off hot/cold cover on handle. This will give you access

to the screw that connects the handle to the cartridge. Using

either an allen key or a flat head screw driver, tighten the screw

so handle has firm connection to cartridge.

2.C - Clog in copper supply pins

2.C - Remove copper pins and flush/clean out.

W68111

Handle Plate

W68113

Cartridge Housing

Cartridge

Cartridge Nut

Handle

68109 CH,BN,MB W

Spout Plate

Spout 68110 W

W68112

W68040

74035 -

1.2 gpm Flow Restrictor 68114 W

W68117 -

Valve Housing W68118 -

1.5 gpm Flow Restrictor

CH,BN,MB

VIGO INDUSTRIES, LLC ("VIGO")

FAUCET LIMITED LIFETIME WARRANTY

EFFECTIVE APRIL 1, 2013

VIGO offers the following limited warranty on each of its Faucet products (the "Product") and the components thereof. This warranty extends only to the original owner

for personal household use. For commercial uses, additional limitations apply.

VIGO warrants the structure of the Product to be free from defects in workmanship and materials under normal use and service for the period commencing from the

initial date of purchase by the owner, contractor, or builder, from VIGO or an authorized VIGO dealer, through the lifetime of the original owner or end-user.

VIGO warrants the cartridge component of the Product to be free from defects in workmanship and materials under normal use and service for a period of five (5) years

from the initial date of purchase by the owner, contractor, or builder, from VIGO or an authorized VIGO dealer.

VIGO warrants the spray assembly and other mechanical components of the Product to be free from defects in workmanship and materials under normal use and

service for a period of one (1) year from the initial date of purchase by the owner, contractor, or builder, from VIGO or an authorized VIGO dealer.

Subject to the Warranty Service provision below, any product reported to the authorized dealer or to VIGO as being defective within the warranty period will be repaired

or replaced (with a product of equal value) at the option of VIGO. This warranty extends to the original owner and is not transferable to a subsequent owner.

Neither the distributor, authorized VIGO dealer, nor any other person has been authorized to make any affirmation, representation, or warranty other than those

contained in this warranty. Any affirmation, representation, or warranty other than those contained in this warranty shall not be enforceable against VIGO or any other

person.

VIGO reserves the right to modify this warranty at any time, it being understood that such modifications will not alter the warranty conditions applicable at the time of

sale of the products in question.

Limitations

This warranty shall not apply to instances of incorrect operating procedures, breakages, or damages caused by fault through improper installation, carelessness, abuse,

misuse, misapplication, improper maintenance, or alteration of the Product, as well as chemical or natural corrosion, accident, fire, flood, an act of God, or any other

casualty. Avoid abrasive cleaners, steel wools, and harsh chemicals as these will scratch, damage, and / or dull the product and / or finish and void this warranty. The

owner of the Product covered by the present warranty is entirely responsible for its proper installation and any applicable plumbing or electrical wiring. VIGO neither

installs nor supervises the installation nor hires a contractor for this purpose; consequently, VIGO cannot be held responsible for any default, breakage, or damages

caused thereby or resulting thereof, either directly or indirectly.

The owner must provide access to the components of the Product as described in the installation guide so that VIGO can execute the warranty specified herein. If such

access is not available, all expenses to provide said access will be the responsibility of the owner.

This warranty does not apply to Products that have not been installed or operated in accordance with instructions supplied by VIGO and all applicable rules, regulations,

and legislation pertaining to such installations.

This warranty does not apply unless the VIGO Product is installed by fully insured licensed professionals. Vigo strongly recommends that such licensed professionals

have experience in the installation of bathroom and kitchen products. [Installation of certain products, including without limitation glass products (i.e., shower doors and

glass sinks) by an inexperienced person may result in product failure including, but not limited to, glass breakage which could result in personal injury or death.]

VIGO is not liable for personal injuries or deaths to any persons or for any direct, special, incidental, or consequential damage, loss of time, loss of profits,

inconvenience, incidental expenses, labor or material charges, or any other costs resulting from the use of the product or equipment or pertaining to the application of

the present warranty, or resulting from the removal or replacement of any product or element or part covered by this warranty.

EXCEPT AS OTHERWISE PROVIDED ABOVE, VIGO MAKES NO WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY

AND FITNESS FOR A PARTICULAR PURPOSE OR COMPLIANCE WITH ANY CODE.

In any case, VIGO cannot be held liable for any amount over and above the purchase price paid for the Product by the owner/end-user, contractor, or builder.

Commercial Limitations

In addition to the above conditions and limitations, the warranty period for products installed for commercial applications or used in commercial ventures is one (1) year

from the initial date of purchase by the owner, contractor, or builder from an authorized dealer. VIGO is not responsible for loss of use or profit under any circumstances.

If the product is used as a display, the warranty period begins from the date of purchase. This warranty gives the owner specific legal rights. The owner may also have

other rights which can vary from one state or province to another.

Warranty Service

In order to obtain service provided under this warranty during regular business hours, contact the dealer or distributor who sold the unit, or contact VIGO directly. VIGO

will provide the warranty service described above when the following conditions have been met: the failure is of the nature or type covered by the warranty; the user has

informed an authorized VIGO Agent or VIGO's warranty service department representative of the nature of the problem during the warranty period; conclusive evidence

(e.g., proof of purchase or installation) is provided to the foregoing by the user proving that the failure occurred or was discovered within the warranty period; an

authorized independent service person or company representative has been permitted to inspect the product during regular business hours within a reasonable time

after the problem was reported by the user. Vigo's warranty obligation shall be discharged upon tender of replacement or repair. The customer's refusal to accept the

tender terminates VIGO's warranty obligations.

Certification may be ended by VIGO or certification agencies without notice.







 HAUTEUR 

DU ROBINET DU JET

VG05005 5 1/8" 6 5/8"

DIMENSIONS











Installation murale et en angle



LISTE DES ARTICLES

Ensemble de robinet



Jet

Cache de jet

Mitigeur





Rondelle



de la CEC de 2016. Si vous avez des questions au sujet de votre



6 5/8"

5 1/8"



VG05005



VUE DE FACE

3 3/8" 3 3/8"

3 3/8"

1 5/8"

5 1/4"

5 1/8"

15/8"

6 5/8"







responsable des modifications et de la touche qui peut venir avec la modification du poste de vente de produits et











bec du robinet. Tirez la plaque de bec loin du mur.





Remplacez avec le connecteur en laiton avec le restricteur orange de 1,5





Connecteur en laiton

Plaque de bec

Connecteur en laiton











Si vous avez des questions, appelez le service de soutien technique de



2. RACCORDEZ LES TUYAUX D'EAU CHAUDE ET D'EAU FROIDE SUR LE



3. FIXEZ LE MITIGEUR AU MUR.





DU JET POUR AVOIR UN ESPACE. VISSEZ LE JET DE SORTE QUE



TROP SERRER LE JET SUR LE MITIGEUR.

NON INCLUS.

VEUILLEZ

CONSULTER UN

PLOMBIER









nettoyants abrasifs, la laine d'acier et































raccords dans le sens des aiguilles d'une montre.





sont pas tous inclus. Cependant, ils sont disponibles dans tout magasin de

plomberie.



Pince multiple

Mastic de plombier

Ruban pour tuyau





EAU

FROIDE

JET

EAU CHAUDE



RONDELLE

ENTRETIEN



POINTS IMPORTANTS



INSTALLATION

ASSEMBLAGE

CONTENU DE L'EMBALLAGE



L'ANCIEN ROBINET ET LES ANCIENS

FLEXIBLES. NETTOYEZ LA SURFACE DU

LAVABO EN VUE DE L'INSTALLATION DU

NOUVEAU ROBINET. RINCEZ AVEC DE L'EAU









FROIDE PENDANT AU MOINS UNE MINUTE. PENDANT QUE L'EAU







MINEURES.





FINI









www.vigoindustries.com

NSF / ANSI 61



 

MESURE CORRECTIVE





3 - Fuites au niveau des points de raccordement











3.A - Fuite du flexible au niveau du point de raccordement

















1.B - Contactez le service de soutien technique de Vigo pour remplacer

la cartouche.



l'eau chaude et replacez la cartouche dans son logement.





pas de fuites.





perpendiculaire au comptoir.













cartouche.



2.C - Retirez les axes en cuivre et rincez/nettoyez-les.





Cartouche







 W

Valve Logement W

Plaque de bec

Bec

68111

68113

68109 CH,BN,MB

68110

68112

68040

74035 -

68114

68117 -

68118 -

CH,BN,MB



VIGO INDUSTRIES, LLC ("VIGO")





usage personnel domestique. D'autres limitations s'appliquent en cas d'usage commercial.





constructeur.









constructeur.











un tiers.





Limitations













directement ou indirectement.















produit, notamment, mais sans s'y limiter, de les briser et de provoquer des blessures, voire la mort.]







SAUF DISPOSITION CONTRAIRE CI-DESSUS, VIGO NE FAIT AUCUNE GARANTIE, EXPRESSE OU IMPLICITE, Y COMPRIS DE VALEUR MARCHANDE,





constructeur.

Limitations commerciales









Service de garantie

















ESPECIFICACIONES DEL GRIFO



Modelo VG05005

MODEL GRIFO BOCA

NRO. ALTURA ALCANCE

VG05005 5 1/8" 6 5/8"

DIMENSIONES

MODELO VG05005













CONTENIDOS DEL PAQUETE

Juego de grifo

Llave Allen

Boca

Cubierta para la boca

Mezclador

Llave

Cubierta para la llave

Arandela

NOTA: Todos los grifos cumplen con CEC 2016 regulaciones. Si

usted tiene preguntas acerca de su flujo de agua, por favor

escriba [email protected].

6 5/8"

5 1/8"



VG05005

VISTA LATERAL

VISTA FRONTAL

3 3/8" 3 3/8"

3 3/8"

1 5/8"

5 1/4"

5 1/8"

15/8"

6 5/8"













La velocidad de flujo con limitador instalado - 1.2 gpm

La velocidad de flujo con limitador dispuesto en el cuadro - 1.5 gpm

NORMAS DE CAUDAL

Afloje los dos tornillos de ajuste en la parte inferior de la

salida. Jale la boquilla del grifo. Tire de la placa de salida de

la pared.

Desatornille y quite el conector de bronce con el restrictor

rosado de 1.2 gpm adentro.





surtidor apretando los dos tornillos de ajuste en la parte inferior del surtidor.



Plato de salida

















MEZCLADOR.



3. FIJE EL MEZCLADOR A LA PARED.

4. USE LA ARANDELA INCLUIDA PARA CONECTAR LA BOCA AL





LA BOCA DE MANERA QUE LA PUNTA MIRE HACIA ABAJO.



NO INCLUIDO.



CONSULTAR CON

UN PLOMERO

CALIFICADO Y CON

LICENCIA.



inconvenientes.



nuevo. Evite usar limpiadores abrasivos, lana de acero y









con gafas de seguridad.















sistema.





las agujas del reloj.



grifo anterior. Si bien no se incluyen todos los recursos necesarios para instalar su



Llave inglesa

Pinzas pico de loro





Destornilladores Phillips y para tornillos de rosca cuadrada

5. CONECTE LA LLAVE.



CALIENTE

BOCA

AGUA CALIENTE

LLAVE

ARANDELA

MANTENIMIENTO

HERRAMIENTAS NECESARIAS

PUNTOS IMPORTANTES

CONSEJOS DE SEGURIDAD



MONTAJE

CONTENIDO DEL

PAQUETE

1. CIERRE EL SUMINISTRO DEL

AGUA. QUITE EL GRIFO VIEJO Y

LAS MANGUERAS FLEXIBLES.

LIMPIE LA SUPERFICIE DEL

LAVABO PARA PREPARARLO

PARA EL NUEVO GRIFO.





ASEGURARSE DE QUE NO

QUEDEN TRABADOS ESCOMBROS













DE SUMINISTRO. EL AJUSTE SUAVE DE LAS TUERCAS DETIENE



NSF / ANSI 61

PIEZA

NRO. DE PIEZA

ACABADO



LISTA DE PIEZAS - 





[email protected]

www.vigoindustries.com



PROBLEMA CAUSA POTENCIAL MEDIDA CORRECTIVA



2 - Caudal insuficiente



4 - Afloje el cuerpo del grifo

1.A - Cartucho no ajustado

1.B - Cartucho defectuoso

2.A - Aireadores sucios





3.B - Arandela defectuosa

4. - Los dispositivos de ensamblaje se aflojaron

3.A - Ajuste las mangueras. Si eso no resuelve el problema,











no abrasivo (es decir, mitad agua caliente, mitad vinagre).















4. - Desde debajo de la encimera, utilice una llave inglesa para





5 - Afloje la llave





al tornillo que conecta la llave con el cartucho. Con una llave Allen o

un destornillador de cabeza gruesa, ajuste el tornillo para que la







completo.

Placa de la llave

Cartucho de vivienda

Cartucho

Tuerca del cartucho

Llave

Restrictor de flujo de 1.5 gpm

Restrictor de flujo de 1.2 gpm W

 W

Placa de salida



68111

68113

68109 CH,BN,MB

68110

68112

68040

74035 -

68114

68117 -

68118 -

CH,BN,MB

VIGO INDUSTRIES, LLC ("VIGO")











comienza en la fecha de compra inicial por parte del propietario, contratista o constructor a VIGO o a un distribuidor autorizado de VIGO y durante toda la vida del propietario o

usuario final originales.









VIGO.















Limitaciones



















aplicables sobre dichas instalaciones.





otros, productos de vidrio (es decir, puertas de duchas y lavabos de vidrio) por parte de personas sin experiencia puede provocar fallos en el producto incluidos, entre otros,















el Producto.

Limitaciones comerciales



























