SINK SPECIFICATIONS
Acrylic Vessel Sink
Model VG04001
MODEL # SINK SINK SINK HOLE
LENGTH WIDTH HEIGHT DIAMETER
VG04001 14 1/2" 14 1/2" 5 " 1 3/4"
DIMENSIONS
MODEL VG04001
FEATURES
PACKING LIST
5"
14 1/2"
TOLL FREE: (866) 591 - 7792
E-Mail: [email protected]
www.vigoindustries.com
For warranty purposes contact our toll free number:
MODEL VG04001
THE MEASUREMENTS IN INCHES ARE ROUNDED TO THE NEAREST 1/8"
TOP VIEW
FRONT VIEW
NOTE:
MATERIAL DIMENSIONS MAY VARY UP TO 3/8"
1 3/4"
5"
14 1/2"
14 1/2"
14 1/2"
13 1/2"
13 1/2"
2
3
To ensure that your installation project goes smoothly, please review these
instructions before proceeding.
Your new lavatory is designed for years of trouble-free performance.
Keep it looking new by cleaning it periodically with a soft cloth. Avoid abrasive
cleaners, steel wool and harsh chemicals. 400 grit sand paper is provided to
remove tough stains. Run warm water over the effected areas and lightly, in a
circular pattern buff out the stain. Please do not over buff as the material will
deform in shape and may not drain properly. Contact Vigo Industries' tech
department with any questions or concerns.
MAINTENANCE
REQUIRED TOOLS
Plumber's putty or Caulk
Caulking Gun
Tape Measure
SAFETY TIPS
Observe all local plumbing and building codes.
Risk of personal injury or product damage. Handle with care. Material can break
or chip if the product is handled carelessly.
Prior to installation, unpack the new lavatory and inspect it for damage. Return the
lavatory to its protective carton until you are ready to install it.
IMPORTANT POINTS
1. Installation must be done by a qualified, licensed plumber. The contractor must
perform a dry fit prior to drilling holes in the counter top for the sink.
3. All Vigo vessel bowls are hand made. You may expect variations in color,
texture and bowl symmetry. If you notice any obvious variation or defects you
should contact your retailer immediately.
4. Though resistant to breakage, vessel sinks can break or chip when a heavy
object falls in or on them.
INSTALLATION
Installation must be done by a qualified licensed plumber.
Prior to installation please read the instructions thoroughly, confirm that all parts
are included and visually inspect the unit for any defects.
If you have any questions please contact the Vigo Technical Support
Department before proceeding with installation.
PACKAGE CONTENTS
LAVATORY
Turn off the water supply. This is done by closing the two shut-off valves
located under the lavatory. If there are no shut-off valves leading to the lavatory,
you must turn off the water at the main valve. This is usually located in the
basement, garage or near the foundation on the outside of the house. It may
also be near the water meter. Check to be sure the water is off by turning on
the faucet where you are working until the water stops flowing. If you have shut
off the main valve in a two-story house or greater, you should open the kitchen
faucet and another faucet on the same level. Water will then drain from the
entire line. This will help avoid spills. Be sure and close the faucets before you
turn on the main valve again. Disconnect the drain pipes. Take off as many
sections as possible between the lavatory and the wall or floor to facilitate
removal. Place a basin under the work area to catch any water that may still be
in the drain.
REMOVING YOUR OLD LAVATORY
ASSEMBLY
ONLY THE SINK IS PROVIDED
Make sure to use the intended style drain / pop-up. The Vigo style vessel bowl
does not have an overflow. Therefore the drain / pop-up needs to
correspond appropriately.
NOT PROVIDED
TAIL PIECE
DRAIN NUT
TO DRAIN
WASHER
DRAIN ASSEMBLY
SOFT WHITE WASHER
POP UP TOP
INTERNAL BRASS PIECE (POP UP MECHANISM)
1. Please inspect your working surface, making sure it is level and clean.
2. Determine the layout for the sink you desire. It is important to fully "dry" position
the sink with your faucet purchase on the countertop. Things to include, but are not
limited to;
desired position.
DO NOT OVER TIGHTEN THE DRAIN
!
POP UP DRAIN
RUBBER WASHER
TAIL PIECE
DRAIN NUT
SOFT WHITE WASHER
POP UP DRAIN TOP
RUBBER WASHER
SINK
COUNTERTOP
TAIL PIECE NUT
COUNTERTOP
INTERNAL BRASS PIECE
(POP UP MECHANISM)
(with stand installed)
WHITE PLASTIC WASHER
WHITE PLASTIC WASHER
4
ACRYLIC SINK LIMITED LIFETIME WARRANTY
EFFECTIVE AUGUST 1, 2014
personal household use. For commercial uses, additional limitations apply.
VIGO warrants the Product to be free from defects in workmanship and materials under normal use and service for the period commencing from the initial date of
purchase by the owner or end-user, contractor, or builder, from VIGO or an authorized VIGO dealer, through the lifetime of the original owner or end-user.
Subject to the Warranty Service provision below, any product reported to the authorized dealer or to VIGO as being defective within the warranty period will be
repaired or replaced (with a product of equal value) at the option of VIGO. This warranty extends to the original owner or end-user and is not transferable to a
subsequent owner.
Neither the distributor, authorized VIGO dealer, nor any other person has been authorized to make any affirmation, representation, or warranty other than those
contained in this warranty. Any affirmation, representation, or warranty other than those contained in this warranty shall not be enforceable against VIGO or any other
person.
VIGO reserves the right to modify this warranty at any time, it being understood that such modifications will not alter the warranty conditions applicable at the time of
sale of the products in question.
Limitations
This warranty shall not apply to instances of incorrect operating procedures, breakages, or damages caused by fault through improper installation, carelessness,
abuse, misuse, misapplication, improper maintenance, or alteration of the Product, as well as chemical or natural corrosion, accident, fire, flood, an act of God, or any
other casualty. Avoid abrasive cleaners, steel wools, and harsh chemicals as these will scratch, damage, and / or dull the product and / or finish and void this
warranty. The owner/end-user of the Product covered by the present warranty is entirely responsible for its proper installation and any applicable plumbing or
electrical wiring. VIGO neither installs nor supervises the installation nor hires a contractor for this purpose; consequently, VIGO cannot be held responsible for any
default, breakage, or damages caused thereby or resulting thereof, either directly or indirectly.
The owner/end-user must provide access to the components of the Product as described in the installation guide so that VIGO can execute the warranty specified
herein. If such access is not available, all expenses to provide said access will be the responsibility of the owner/end-user.
This warranty does not apply to Products that have not been installed or operated in accordance with instructions supplied by VIGO and all applicable rules,
regulations, and legislation pertaining to such installations.
This warranty does not apply unless the VIGO Product is installed by fully insured licensed professionals. Vigo strongly recommends that such licensed professionals
have experience in the installation of bathroom and kitchen products. Installation of certain products, including, without limitation, glass products (i.e., shower doors
and glass sinks) by an inexperienced person may result in glass breakage and, consequently, cause personal injury or death.
VIGO is not liable for personal injuries or deaths to any persons or for any direct, special, incidental, or consequential damage, loss of time, loss of profits,
inconvenience, incidental expenses, labor or material charges, or any other costs resulting from the use of the product or equipment or pertaining to the application of
the present warranty, or resulting from the removal or replacement of any product or element or part covered by this warranty.
EXCEPT AS OTHERWISE PROVIDED ABOVE, VIGO MAKES NO WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE OR COMPLIANCE WITH ANY CODE.
In any case, VIGO cannot be held liable for any amount over and above the purchase price paid for the Product by the owner/end-user, contractor, or builder.
Commercial Limitations
In addition to the above conditions and limitations, the warranty period for products installed for commercial applications or used in commercial ventures is one (1)
year from the initial date of purchase by the owner/end-user, contractor, or builder from an authorized dealer. VIGO is not responsible for loss of use or profit under
any circumstances. If the product is used as a display, the warranty period begins when the product is placed on display. This warranty gives the owner/end-user
specific legal rights. The owner/end-user may also have other rights which can vary from one state or province to another.
Warranty Service
In order to obtain service provided under this warranty during regular business hours , contact the dealer or distributor who sold the unit, or contact VIGO directly.
VIGO will provide the warranty service described above when the following conditions have been met: the failure is of the nature or type covered by the warranty;
the user has informed an authorized VIGO Agent or VIGO's warranty service department representative of the nature of the problem during the warranty period;
conclusive evidence (e.g., proof of purchase or installation) is provided to the foregoing by the user proving that the failure occurred or was discovered within the
warranty period; an authorized independent service person or company representative has been permitted to inspect the product during regular business hours within a
reasonable time after the problem was reported by the user. VIGOs warranty obligation shall be discharged upon tender of replacement or repair. The customer's
refusal to accept the tender terminates VIGO's warranty obligations.
*Certain models are pending approval.
Certification may be ended by VIGO or certification agencies without notice.
Lavabo en verre de type vasque
DU LAVABO DU LAVABO DU LAVABO DE L'ORIFICE
VG04001 14 1/2" 14 1/2" 5" 1 3/4"
DIMENSIONS
Ouverture du drain standard
Surface non poreuse
Fini mat
Installation sur un comptoir
LISTE DES ARTICLES
Vasque
5"
14 1/2"
Sans frais: (866) 591-7792
Courriel: [email protected]
www.vigoindustries.com
Pour toute question concernant la garantie, composez
VUE DE DESSUS
VUE DE FACE
1 3/4"
5"
14 1/2"
14 1/2"
14 1/2"
13 1/2"
13 1/2"
2
3
les nettoyants abrasifs, la laine d'acier et les produits chimiques puissants.
ENTRETIEN
Mastic ou calfeutrage de plombier
Vous risqueriez de vous blesser ou d'endommager le produit. Manipulez le produit
POINTS IMPORTANTS
1.
le comptoir pour installer le lavabo.
INSTALLATION
vous avez des questions, appelez le service de soutien technique de Vigo avant de
CONTENU DE L'EMBALLAGE
LAVABO
plus grand nombre de sections de drain possibles entre le lavabo et le mur ou le sol.
ASSEMBLAGE
SEUL LE LAVABO EST FOURNI
propre.
dans la position voulue.
3. Marquez et percez un trou de 0 1 3/4" sur le comptoir afin de placer le drain.
COMPTOIR
COMPTOIR
NON INCLUS
VERS LE DRAIN
RONDELLE
ENSEMBLE DE DRAIN
SOUPLE BLANCHE
DESSUS DE LA BONDE
NE SERREZ PAS TROP LE DRAIN
!
DRAIN DE LA BONDE
RONDELLE DE CAOUTCHOUC
RONDELLE SOUPLE
DESSUS DU DRAIN
RONDELLE DE CAOUTCHOUC
LAVABO
RONDELLE EN
RONDELLE EN PLASTIQUE BLANCHE
RACCORDEMENT
RONDELLE
BLANCHE
DE LA BONDE
PLASTIQUE BLANCHE
DE RACCORDEMENT
4
utilisateur final en vue d'un usage personnel domestique. D'autres limitations s'appliquent en cas d'usage commercial.
l'entrepreneur ou le constructeur.
Limitations
l'installation de certains produits, y compris sans toutefois s'y limiter, les produits en verre (portes de douches et lavabos en verre) sont susceptibles de les briser et, par
SAUF DISPOSITION CONTRAIRE CI-DESSUS, VIGO NE FAIT AUCUNE GARANTIE, EXPRESSE OU IMPLICITE, Y COMPRIS DE VALEUR
le constructeur.
Limitations commerciales
Service de garantie
5"
14 1/2"
ESPECIFICACIONES DEL LAVABO
Lavabo de vidrio
Modelo VG04001
MODELO ARGO ANCHO ALTO
NRO. DEL LAVABO DEL LAVABO DEL LAVABO DEL ORIFICIO
VG04001 14 1/2" 14 1/2" 5" 1 3/4"
DIMENSIONES
MODELO VG04001
CONTENIDOS DEL PAQUETE
www.vigoindustries.com
MODELO VG04001
1 3/4"
5"
14 1/2"
14 1/2"
14 1/2"
VISTA SUPERIOR
VISTA FRONTAL
2
3
MANTENIMIENTO
HERRAMIENTAS NECESARIAS
Masilla de plomero o calafatear
Pistola para calafatear
CONSEJOS DE SEGURIDAD
listo para instalarlo.
PUNTOS IMPORTANTES
1. . El contratista
debe posicionarlo en seco antes de hacer los orificios en la parte superior de la
mesa del lavabo.
4. Si bien son resistentes a roturas, los lavabos pueden quebrarse o picarse
cuando caen objetos pesados dentro de ellos o sobre ellos.
CONTENIDO DEL PAQUETE
LAVABO
MONTAJE
y limpia.
posicionar el lavabo por completo "en seco" con el grifo comprado en la encimera.
Alguna de las cosas a considerar, entre otras:
!
TUERCA DE
ARANDELA BLANCA
PARTE SUPERIOR DEL
ARANDELA BLANCA
LAVABO
ENCIMERA
PIEZA INTERNA DE BRONCE
EMERGENTE)
ARANDELA DE CAUCHO
NO INCLUIDO
TUERCA DE
ARANDELA
ARANDELA BLANCA
PIEZA INTERNA DE BRONCE
ARANDELA DE CAUCHO
ENCIMERA
BLANDA
BLANDA
ARANDELA BLANCA
DE CAUCHO
4
compra inicial por parte del propietario/ usuario final, contratista o constructor a VIGO o a un distribuidor autorizado de VIGO y durante toda la vida del propietario o usuario final
originales.
para el propietario o usuario final originales y no es transferible a propietarios posteriores.
Limitaciones
aplicables sobre dichas instalaciones.
productos de vidrio (es decir, puertas de duchas y lavabos de vidrio) por parte de personas sin experiencia puede provocar ruptura del vidrio y, por ende, lesiones personales o la
muerte.
Producto.
Limitaciones comerciales
estado o la provincia.
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
